Toyota Avensis ZZT251 2003 Service And Repair Manual page 1172

41–30
MANUAL TRANSMISSION/TRANSAXLE
56. INSTALL BATTERY TRAY
57. INSTALL BATTERY
58. INSTALL BATTERY CLAMP SUB–ASSY
Torque:
Bolt: 5.0 N m (51 kgf cm, 44 in. lbf)
Nut: 3.5 N m (36 kgf cm, 31 in. lbf)
59. INSTALL AIR CLEANER ASSY
Torque: 5.0 N m (51 kgf cm, 44 in. lbf)
60. INSTALL ENGINE COVER SUB–ASSY NO.1
Torque: 9.0 N m (92 kgf cm, 80 in. lbf)
61. INSTALL ENGINE ROOM COVER SIDE
62. INSTALL RADIATOR SUPPORT OPENING COVER
63. INSTALL HOOD SUB–ASSY
Torque: 13 N m (132 kgf cm, 10 ft lbf)
64. INSPECT HOOD SUB–ASSY
65. ADJUST HOOD SUB–ASSY
66. ADD TRANSAXLE OIL
67. INSPECT TRANSAXLE OIL
68. INSTALL FRONT WHEELS
Torque: 103 N m (1,050 kgf cm, 76 ft lbf)
69. INSTALL STEERING INTERMEDIATE SHAFT
70. INSTALL STEERING COLUMN HOLE COVER SUB–ASSY NO.1 (See
71. INSTALL STEERING INTERMEDIATE SHAFT ASSY NO.2
72. INSTALL COLUMN HOLE COVER SILENCER SHEET
73. PLACE FRONT WHEELS FACING STRAIGHT AHEAD
74. STEERING WHEEL CENTER POINT
75. ADD POWER STEERING FLUID
76. BLEED POWER STEERING FLUID
77. CHECK POWER STEERING FULUID LEVEL IN RESERVER
78. INSPECT FLUID LEAK
79. INSPECT FRONT WHEEL ALIGNMENT
80. INSTALL ENGINE UNDER COVER LH
81. INSTALL ENGINE UNDER COVER RH
82. CHECK ABS SPEED SENSOR SIGNAL
(a) w/ VSC (See page
(b) w/o VSC (See page
83. HEADLIGHT AIM ONLY (W/ DISCHARGE HEAD LAMP)
AVENSIS REPAIR MANUAL (RM1018E)
55.
(a)
D30080
(See page 75–2)
(See page 75–2)
(See page 41–5)
(See page 41–2)
(See page
(See page 51–4)
(See page
05–756)
05–699)
http://vnx.su
– MANUAL TRANSAXLE ASSY (1AZ–FE/1AZ–FSE)
INSTALL BATTERY CARRIER
Install the battery carrier and 4 bolts.
Torque: 13 N m (131 kgf cm, 9 ft lbf)
(See page 50–9)
(See page
(See page
51–4)
(See page
26–6)
(See page
page)See page 50–9)
50–9)
50–9)
51–4)
65–19)