Table of Contents
Advertisement
38.
REMOVE UN–LOCK WARNING SWITCH ASSY
(a)
Slide the unlock warning switch assy out of the steering column upper bracket.
39.
REMOVE IGNITION OR STARTER SWITCH ASSY
(a)
Remove the 2 screws and ignition or starter switch assy.
40.
INSTALL IGNITION OR STARTER SWITCH ASSY
(a)
Install the ignition or starter switch assy to the steering column upper w/switch bracket assy with the
2 screws.
41.
INSTALL UN–LOCK WARNING SWITCH ASSY
(a)
Install the un–lock warning switch assy.
(b)
Connect the un–lock warning switch assy connector to the ignition or starter switch assy.
42.
INSTALL IGNITION SWITCH LOCK CYLINDER ASSY
(a)
Make sure of the ignition switch lock cylinder assy at the ACC position.
(b)
Install the ignition switch lock cylinder assy.
43.
INSPECT STEERING LOCK OPERATION
(a)
Check that the steering lock mechanism is activated when removing the key.
(b)
Check that the steering lock mechanism is deactivated when inserting the key and turning it to ACC
position.
Matchmarks
AVENSIS REPAIR MANUAL (RM1018E)
STEERING COLUMN
–
STEERING COLUMN ASSY
44.
INSTALL TRANSPONDER KEY AMPLIFIER
(a)
Align the transponder key amplifier with the installation
position of the upper bracket with the amplifier inclined.
(b)
Push the transponder key amplifier up and connect it to
the upper bracket.
NOTICE:
Take care not to push the amplifier up with excessive force
to prevent it from being damaged.
F44798
45.
INSTALL STEERING COLUMN UPPER W/SWITCH
BRACKET ASSY
(a)
Temporarily install the steering column upper with switch
bracket assy and steering column upper clamp with 2 new
tapered–head bolts.
(b)
Tighten the 2 tapared–head bolts until the bolt heads
break off.
F44799
46.
INSTALL STEERING SLIDING YOKE SUB–ASSY
(RHD STEERING POSITION TYPE)
(a)
W/VSC:
Install the steering sensor
(b)
Align matchmarks on the steering sliding yoke and steer-
ing main shaft.
(c)
Oil Pressure Power Steering
(1)
Install the steering sliding yoke with the bolt.
Torque: 28 N m (286 kgf cm, 21 ft lbf)
F44793
http://vnx.su
(See page
32–65).
50–15
Advertisement
Table of Contents
