Chrysler neon 1997 Service Manual page 1306

SPEED THROTTLE LEVER CONTROL CABLE
PL
REMOVAL AND INSTALLATION (Continued)
CABLE
Fig. 39 Throttle Cable Attachment to Throttle Body
Fig. 40 Disconnecting Throttle Cable
INSTALLATION
(1) From the engine compartment, push the hous-
ing end fitting into the dash panel grommet.
(2) Install cable housing (throttle body end) into
the cable mounting bracket on the engine.
(3) From inside the vehicle, hold up pedal and feed
throttle cable core wire through hole in upper end of
the pedal shaft. Install cable retainer.
(4) Install cable retainer clip.
(5) From the engine compartment, rotate the
throttle lever forward to the wide open position and
install cable clasp (Fig. 40).
(6) Install throttle control shield (Fig. 38). Tighten
screw to 5.6 N·m (50 in. lbs.).
THROTTLE CABLE—AUTOMATIC TRANSMISSION
REMOVAL
(1) Remove throttle control shield (Fig. 38).
(2) Working from the engine compartment, remove
throttle cable from throttle body cam (Fig. 41) and
(Fig. 42).
TABS
CLASP
THROTTLE CABLE SPEED TROL CABLE CON-
Fig. 41 Throttle Body Cables Attachment to Throttle
Fig. 42 Disconnecting Throttle Cable
(3) Compress the retaining tabs on the cable and
slide cable out of bracket.
(4) From inside the vehicle, hold the throttle pedal
up and remove the cable retainer and cable from
upper end of pedal shaft (Fig. 36) and (Fig. 37).
(5) Remove retainer clip from throttle cable and
grommet at the dash panel.
(6) From the engine compartment, pull the throttle
cable out of the dash panel grommet. The grommet
should remain in the dash panel.
INSTALLATION
(1) From the engine compartment, push the hous-
ing end fitting into the dash panel grommet.
(2) Install cable housing (throttle body end) into
the cable mounting bracket on the engine.
(3) From inside the vehicle, hold up pedal and feed
throttle cable core wire through hole in upper end of
the pedal shaft. Install cable retainer (Fig. 37).
(4) Install cable retainer clip.
CABLE CLASP THROTTLE CABLE TRANSMISSION KICKDOWN CABLE TABS
FUEL SYSTEM
Body
14 - 19