To Set Low Range; For Traction; Engine - Toro Groundsmaster 5900 Series Service Manual

TO SET LOW RANGE

FOR TRACTION

ENGINE

Groundsmaster ® 5900 & 5910
16227SL Rev B
The TO SET LOW RANGE advisory identifies that low range traction speed will
not engage when the High/Low range traction speed switch is pressed.
#602 DISENGAGE Cruise control is engaged and needs to be disengaged in order to engage
CRUISE: low speed range.
#603 REDUCE Ground speed needs to be less than 2 MPH in order to engage low speed
GROUND SPEED: range.
#604 REQUIRES CAN communication between the two (2) Toro Electronic Controllers
SERVICE: (TEC) must be reestablished before low speed range can be engaged.
The FOR TRACTION advisory identifies that the traction drive will not engage
when the traction pedal is pressed.
#806 OPERATOR Operator needs to be in seat to engage traction.
MUST BE
SEATED:
#804 RELEASE Parking brake is applied and needs to be released before traction drive
PARKING BRAKE: will engage.
#805 MOVE The traction pedal needs to be in the neutral position before engaging
TRACTION PEDAL forward or reverse operation.
TO NEUTRAL:
The ENGINE advisory identifies conditions that may reduce engine performance.
#1205 30 SECOND Engine starter has been disabled after being engaged (cranking) for 30
STARTER TIME seconds. Recycle key switch.
OUT:
#1206 CHECK AIR A high vacuum condition exists in the air cleaner body indicating the air
FILTER: filter element may require replacement.
#1207 SERVICE This message will appear twenty (20) hours before scheduled service is
DUE X HOURS: due. The message will reappear at two (2) engine hour increments until
the service timer is reset.
#1208 PAST DUE This message will appear when the scheduled service timer has expired.
X HOURS: This message will appear at two (2) engine hour increments until the
service timer is reset.
#1209 Due to a high pressure differential in the diesel particulate filter (DPF), the
REGENERATION engine ECU has requested a stationary regeneration be performed. This
REQUIRED is a serious condition and should be addressed in a timely matter.
WITHIN 30
MINUTES:
#1210 LET The engine coolant temperature has exceeded 105 ºC (221 ºF). The
ENGINE COOL: maximum engine RPM will be reduced by the engine ECU until the coolant
temperature is lowered. The engine will not be shut off by the engine ECU
due to a high temperature condition.
Page 3–19 Troubleshooting: