PIAGGIO MP3 530 hpe Service Station Manual page 164

Machine Translated by Google
MP3 530 hpe
12 - Definitely replace the starter remote relay.
13 - Check the battery again and replace the starter motor if necessary.
ANNOTATION
IF THE CRANKSHAFT DRIVE SPEED IS LOW AND UNUSUAL NOISE IS PRODUCED AT THE SAME
TIME, THE FREEWHEEL AND TORQUE LIMITER MUST BE CHECKED (SEE CHAPTER "ALTERNATOR
AND STARTING SYSTEM").
gear ring and freewheel coaxial with the flywheel.
The starter system consists of a drive between the starter motor armature and the crankshaft
Freewheel mounted coaxially to the flywheel and torque limiter on the intermediate shaft.
The torque limiter is calibrated to 10 kgm (100 N m). This component is used to protect the
Conditions of the engine and the starter gear in the event of an incorrect starting process with rotation in Ge
direction.
The freewheel enables sufficiently quiet starting.
The start signal (triggering of the remote relay) is via the start release switches on the side stand and
The emergency stop switch is released (OFF/RUN), meaning the vehicle cannot be started in the event of danger
become.
The starter control circuit is not monitored by the immobilizer system. Before the occasion
If the power system is somehow bypassed, the immobilizer should first enable the start
be checked.
For checking the circuits for start release, see the "Electrical system" chapter. For the
Checks for driving the crankshaft as described in the "Alternator and starter system" chapter
ben proceed.
Removing the starter motor
ANNOTATION
THE STARTER MOTOR CAN BE REMOVED EVEN WITH THE ALTERNATOR COVER INSTALLED.
STARTER MOTOR
Technical information
Type
Performance
Technical information
capacity
Starting current
REMOTE STARTER RELAY
Technical information
Type
payload
STARTER TRANSMISSION
Technical information:
Description/Value
BATTERY
Description/Value
Description/Value
MAINTENANCE FREE
Description/Value
Intermediate gear integrated with torque limiter.
Mitsuba sm13d
0,9 kW
14 Ah
125 A
150 A constantly
AGAINST - 167
Motor