Table of Contents
Advertisement
A. ELECTRICAL AND ELECTRONIC ABNORMALITIES:
Often times the operator or technician may assume or be confused in thinking that a problem with the Ultra
Whisper operation is due to an Electrical or Electronic Abnormality when in fact the cause of the operational
abnormality may be due to simple lack of maintenance such as a plugged Prefilter Element. For example, the
system continually shuts down; the operator thinks there is an electrical problem or pressure switch problem; in fact
the prefilter is plugged up and the pressure switch is protecting the System by shutting the system down as it is
designed to do.
Always check and compare against normal the Pressure Gauge readings prior to assuming that the System has an
electrical or electronic abnormality.
ELECTRICAL verses ELECTRONIC abnormalities:
ELECTRICAL refers to the High Voltage or Power Voltage that supplies the Ultra Whisper System.
ELECTRONIC refers to the Low Voltage and Electronic Circuitry that controls the System.
Prior to Troubleshooting Properly Position Valves
a) Ensure that the Sea Cock Valve [2] is fully open.
b) Ensure that the Inlet Rinse Clean Valve [36], if installed, is positioned towards the Sea Strainer [4]
normal operating position.
c) Ensure that the Discharge Rinse Clean Valve [37], if installed, is positioned towards the Brine Discharge
fitting [22] normal operating position.
d) Ensure that any valve in the Brine Discharge Line or at the Thru Hull Discharge Fitting [22] is full
OPEN.
e) Ensure that any valve in the Product Water Line is full OPEN.
f) Ensure that there are no kinks or other blockages in the Brine Discharge Line and or the Product Water
Line.
CAUTION: ELECTRICAL SHOCK HAZARD. A Volt / Ohm Meter will be necessary for some troubleshooting and
subsequent corrective actions. The following procedures expose the technician to High Voltage and electrical shock
hazard. Only attempt this if you are a qualified electrician and only if surrounding conditions are safe.
section 6 page 32 of 38
Sea Recovery Ultra Whisper Rev. A
Advertisement
Table of Contents
