Table of Contents
Advertisement
Sea Recovery Ultra Whisper Rev. A
G. Connect all required hoses and tubes: (** = Supplied by Installer or Owner; *** = Optional Accessory.)
1. Connect Feed and Fresh Water Flush Lines with the supplied 20 feet (6 meters) of 1/2" (12.7 mm) I.D. Inlet
Suction Hose. Secure the hose with two hose clamps offset 180 degrees at each fitting. Ignore any Optional
Accessory that is not to be installed and move to the next component. Refer to Piping and Interconnect
diagrams on pages 42 and 43:
Step
from Outlet of
1.
Feed Water Connector [3]
2.
Sea Strainer [4]
3.
**Rinse/Clean bucket or container [38]
4.
***Inlet 3-way Clean/Rinse Valve [36]
(center port)
5.
Feed Pump [6]
6.
Fresh Water Flush Check Valve [35]
7.
***Plankton Filter [7]
8.
Inline Pressure Pick-Up Tee [8]
9.
Prefilter 5 micron [14]
10.
Inline Pressure Pick-Up Tee [15]
11.
**Unpressurized Potable Water Tank line [32]
12.
Fresh Water Flush Carbon Filter [34]
2. Connect Brine Discharge line with the supplied 20 feet (6 meters) of 3/8" (9.5 mm) O.D. Brine Discharge Tubing:
Step
from Outlet of
1.
ETD [17] Port "S" Brine Discharge Outlet
refer to illustration on page 46
2.
***Discharge 3-Way Rinse Clean Valve [37]
(left or right port)
3.
***Discharge 3-Way Rinse Clean Valve [37]
(left or right port)
3. Connect Product Water line with the supplied 30 feet (9.14 meters) of 3/8" (9.52 mm) O.D. nylon tubing:
Step
from Outlet of
1.
Membrane Product Water connector [20]
1.
Product Water Manifold [24] Port "B" Unpotable
refer to illustration on page 47
2.
Product Water Manifold [24] Port "A" Potable
refer to illustration on page 47
3.
Charcoal Filter [28]
4.
***pH Neutralizing Filter [29]
5.
***U.V. Sterilizer [30]
to Inlet of
Sea Strainer [4]
***Inlet 3-Way Clean/Rinse Valve [36]
(left or right port)
***Inlet 3-way Clean/Rinse Valve [36]
(left or right port)
Feed Pump[6]
Fresh Water Flush Check Valve [35]
***Plankton Filter [7]
Inline Pressure Pick-Up Tee [8]
Prefilter 25 micron [13]
Inline Pressure Pick-Up Tee [15]
ETD [17] port "E" Feed Water Inlet
refer to illustration on page 46
Fresh Water Flush Pressure Pump [33]
Fresh Water Flush Check Valve [35]
to Inlet of
***Discharge 3-Way Rinse Clean Valve [37]
(center port)
**Rinse Clean bucket or container [38]
Brine Discharge Connector [22]
Section 2 Page 62 of 68
to Inlet of
Product Water Manifold [24] Inlet
refer to illustration on page 47
Brine Discharge Tee [21]
Charcoal Filter [28]
***pH Neutralizing Filter [29]
***U.V. Sterilizer [30]
**Potable Water Tank Connector [31]
Advertisement
Table of Contents
