Check Points Of Every 100 Hours - Kubota GR1600EU Workshop Manual

GR1600EU, WSM

[3] CHECK POINTS OF EVERY 100 HOURS

Checking Fuel Line and Fuel Filter
CAUTION
To avoid personal injury:
• Be sure to stop the engine and remove the key when
attempting to make the following checks and changes.
• Never fail to check the fuel lines periodically. The fuel lines
are subject to wear and aging. Fuel may leak out onto the
running engine, causing a fire.
The fuel line connections should be checked annually or every
100 service hours, whichever comes first.
1. The fuel line (2) is made of rubber and ages regardless of
service period.
2. If the fuel line (2) and clamps (1) are found to be damaged or
deteriorated, replace them.
3. Check fuel filter (3), if it is clogged by debris or contaminated
with water, replace it.
IMPORTANT
• When the fuel line is disconnected for maintenance or
repair, close both ends of the fuel line with a piece of clean
cloth or paper to prevent dust and dirt from entering. In
addition, particular care must be taken not to admit dust
and dirt into the fuel pump. Entrance of even a small
amount of dust or dirt cause premature wear and
malfunction of the fuel pump and injector components.
(1) Pipe Clamp
(2) Fuel Line
G-32
GENERAL
(3) Fuel Filter
9Y1210595GEG0021US0
KiSC issued 11, 2013 A