Evinrude 4906B 4HP 1969 Owner's Manual page 337

9-2 HAND STARTERS
arm roves the drive gear upward to engage
\-, vith the teeth of the Ilvvbeel r ins; gear.
coil spring winds and tightens
unwinds. The spring then coils the rope
around a pulley as the rope handle is return-
ed to the control panel.
Service procedures
are presented in Section 9-4.
Type III
This type starter
flywheel with three mounting legs attached
to the power head.
of a starting rope and handle,
spring, and an arrangement
corresponding clutch dogs.
assembly is contained
by three legs extending to the power head.
When the starter
pawls automatically
attached to the flyweel and the engine is
cranked.
Three models of this type starter may be
installed on various
gines covered in this manual.
The first model contains pawls with re-
turn springs, a center
spring-release dogs that
Ilywheel ring gear when the starter
pulled. Service procedures are presented
Section 9-5.
The second model does not have spring
pawls or a center cone, but has friction-type
dogs. Service procedures
tion 9-6.
The third model has only one nylon pawl
which engages into cut-a-ways
edge of the flywheel.
for this model are in Section 9-7.
Swing arm type starter
4
3 hp and hp engines.
as the rope
for this hand starter
is mounted atop the
The mechanism consists
a rewind
of pawls and
The complete
in a housing secured
rope is pulled,
engage the clutch dogs
Johnson/Evinrude
cone, and a set of
engage with the
rope is
are given in Sec-
in the outer
Service procedures
mounted on the port side
A
the
Starter mounted atop the flywheel.
the three pawls with return springs.
be
may found
engines.
en-
OPERATION
Normally,
countered
strictly a mechanical
in engine for starting.
incredibly long time, if used properly.
greatest enemy of the spring is the opera-
tor.
Starter mounted
starter has the three pawls, with
on return springs.
33 hp, and 40 hp engines.
This starter
on 28 35
the hp, 30 hp,
very few problems
with the hand starter.
device to crank the
The spring
atop the flywheel.
a friction
be
This model may found
This unit has
model
hp, and 40 hp
are en-
It is
w
ill last an
The
This model
disc and no
on 28
the hp,