BODY 1B-52
Fig.
108 - In stalling Door W indow Glass
vent channel to glass division channel just below vent
latch.
7. Install special flat washer, nylon friction bushing and
friction clamp on vent lower channel pivot shaft, po
sitioned as shown in Figure 111. Attach friction
clamp to vent lower frame with screw.
screw (fig. I l l ) to obtain two to four lbs. torque
while moving vent window from a ten degree'open po
sition to a full-open position. Use either a push or
pull-type spring scale positioned at rear edge of
glass.
. Install small access panel to inner side of door.
8
DOOR WEATHERSTRIP
Removal and Installation
1. Remove three screw-retained clips from weather
strip around perimeter of door.
NOTE:
Figure 112 shows view of weatherstrip
installed at retainer clip.
S H A R P C O R N E R
C H A N N E L
C E N T E R E D
B E T W E E N
C O R N E R S
O F
G L A S S
G L A Z I N G
R U B B E R
Fig.
109 - Door Window G lass Assembly
D O O R
W I N D O W
A S S E M B L Y
Tighten
R O U N D
C O R N E R
S M O O T H
S ID E
O F
C H A N N E L
T H IS
S ID E
F O R
R IG H T
D O O R
G L A S S
A S S E M B L Y
Fig.
110 - Cross Section of W indow Assembly
2. Pull weatherstrip from door, then scrape any rubber
or adhesive material which may have become bonded
to door surface.
3. Apply weatherstrip adhesive as directed by manu
facturer of adhesive. Directions for application are
usually found on adhesive container.
4. Position seal around perimeter of door making sure
corners of seal engage respective corners of door.
5. Install three screw-retained clips to door and weath
erstrip.
Tighten clip screws firmly.
V E N T W I N D O W
G L A S S
FLAT W A S H E R
N Y L O N
F R IC T IO N
B U S H I N G
F R IC T IO N
C L A M P
C L A M P
S C R E W
Fig.
I l l - Door Vent Window
PIVOT SCREW
ACCESS HOLE
VENT WINDOW
DIVISION
TOP RETAINING
CHANNEL
SCREWS
SCREW
A C C E S S H O L E
T O P IV O T S C R E W
V E N T W I N D O W
O U T E R
F R A M E A N D
R U B B E R S E A L
D IV IS IO N C H A N N E L
F R A M E S C R E W
B R A C K E T T O P A N E L S C R E W
mm
BR A C K E T
CHEVROLET TRUCK SERVICE M ANUAL