General Specifications (500 - Manual Transmission) - Arctic Cat 400 Service Manual

General Specifications*
(500 - Manual Transmission)
Type
Main Jet
Slow Jet
Pilot Screw Setting (turns)
Jet Needle
Idle RPM
(engine warm)
Starter Jet
Float Arm
Height
Throttle Cable Free-Play (at
lever)
Ignition Timing
Spark Plug Type
Spark Plug Gap
Spark Plug Cap
Ignition Coil
Resistance
(secondary)
Ignition Coil
Peak Voltage
Magneto Coil
Resistance
Magneto Coil
Peak Voltage
Stator Coil Out-
put
Magneto Output (approx)
Brake Type
Tire Size
Tire Inflation
Pressure
Back
1-4
CARBURETOR
Keihin CVK36
138
40
1 3/4
NFKG
1250-1350
85
17 mm (0.7 in.)
3-6 mm (1/8-1/4 in.)
ELECTRICAL
10° BTDC @ 1500 RPM
NGK CR6E
0.7-0.8 mm (0.028-0.032
in.)
8000-12,000 ohms
(primary) Less than 1 ohm
(terminal to ground)
5200-7800 ohms
(high tension - plug cap
removed - to ground)
(primary/ 140-215 volts
CDI) (terminal to ground)
(trigger) 160-240 ohms
(green to blue)
(source) Less than 1 ohm
(yellow to white)
(charging) Less than 1 ohm
(black to black)
(trigger) 4.2-6.3 volts (green to blue)
(source) 0.40-0.62 volt
(yellow to white)
(no load) 60 AC volts @ 5000 RPM
(black to black #1)
(black to black #2)
325W @ 5000 RPM
CHASSIS
Hydraulic w/Brake Lever
Lock and Auxiliary Brake
Front - 25 x 8-12
Rear - 25 x 11-12
0.35 kg/cm² (5 psi)
Back to TOC
MISCELLANY
Gas Tank Capacity (rated)
Coolant Capacity
Differential Capacity
Rear Drive Capacity
Engine Oil Capacity
Gasoline (recommended)
Engine Oil (recommended)
Differential/Rear Drive Lubricant
Brake Fluid
Taillight/Brakelight
Headlight
* Specifications subject to change without notice.
** At the oil level plug threads.
*** At the filler plug threads.
Back to Section TOC
24.6 L (6.5 U.S. gal.)
2.9 L (3.0 U.S. qt)
275 ml (9.3 fl oz)**
250 ml (8.5 fl oz)***
3.4 L (3.5 U.S. qt)
87 Octane Regular
Unleaded
SAE 10W-40
SAE Approved
80W-90 Hypoid
DOT 4
12V/8W/27W
12V/27W (2)
Next