Torque Specifications; General Specifications - Arctic Cat 1000 XT 2014 Service Manual

General Information

NOTE: Some photographs and illustrations used in
this section are used for clarity purposes only and are
not designed to depict actual conditions.

NOTE: Whenever a part is worn excessively, cracked,
or damaged in any way, replacement is necessary.

General Specifications

MISCELLANY
Tire Size
Tire Inflation Pressure
Spark Plug Type
Spark Plug Gap
Gas Tank Capacity
Coolant Capacity
Differential Capacity
Rear Drive Capacity
Engine Oil Capacity (approx)
Gasoline (recommended)
Engine Oil (recommended)
Front Differential/Rear Drive Lubricant
Drive Belt Width (minimum)
Brake Fluid
Taillight/Brakelight
Headlight
ELECTRICAL SYSTEM
Ignition Timing
Spark Plug Cap
Ignition Coil Resistance (primary)
(secondary)
Ignition Coil Primary Voltage
Stator Coil (crankshaft position sensor)
Resistance (AC generator)
Crankshaft Position Sensor AC Voltage
Generator Output (no load)
Specifications subject to change without notice.
* One inch below plug threads.
** At the plug threads.
2
Front - 26 x 9-12
Rear - 26 x 11-12
0.35 kg/cm² (5 psi)
NGK CPR8E
0.5-0.6 mm (0.019-0.024
in.)
21.6 L (5.7 U.S. gal.)
3.3 L (3.5 U.S. qt)
275 ml (9.3 fl oz)*
250 ml (8.5 fl oz)**
2.6 L (2.75 U.S. qt) -
Overhaul
1.9 L (2.0 U.S. qt) - Change
87 Octane Regular
Unleaded
Arctic Cat ACX All Weather
(Synthetic)
SAE Approved 80W-90
Hypoid
35.6 mm (1.40 in.)
DOT 4
12V/8W/27W
12V/27W (2)
10° BTDC @ 1500 RPM
5000 ohms
4.8 ohms
12k-19k ohms
Battery Voltage
150-250 ohms
Less than 1 ohm
2.0 volts or more
75 AC volts or more @ 5000
RPM

Torque Specifications

EXHAUST COMPONENTS
Part
Exhaust Pipe Engine
Spark Arrester Muffler
ELECTRICAL COMPONENTS
Coil Air Filter Housing
STEERING COMPONENTS
Steering Post Bearing Housing Frame
Steering Post Bearing Flange Frame
Lower Steering Bearing Steering Post
Washer Cap Screw***
Tie Rod End Knuckle/Steering Post
EPS Housing Frame
BRAKE COMPONENTS
Brake Disc* Hub
Brake Hose Caliper
Brake Hose (Banjo-Fitting) Master Cylinder
Brake Hose Auxiliary Brake Cylinder
Master Cylinder (Rear) Frame
Hydraulic Caliper Knuckle (w/"Patch-Lock") 20
Master Cylinder Clamp Master Cylinder
Brake Pedal Brake Pedal Axle
CHASSIS COMPONENTS
Footrest Frame (8 mm)
Footrest Frame (10 mm)
SUSPENSION COMPONENTS (Front)
A-Arm Frame
Knuckle Ball Joint
Shock Absorber Frame/Upper A-Arm
Ball Joint A-Arm
SUSPENSION COMPONENTS (Rear)
Shock Absorber (Upper) Frame
Shock Absorber (Lower) Lower A-Arm
A-Arm Frame
Knuckle A-Arm
DRIVE TRAIN COMPONENTS
Front Differential Frame/Differential
Bracket
Rear Gear Case Frame
Pinion Housing Differential Housing
Differential Housing Cover*** Differential Housing
Lock Collar Differential Housing
Hub Nut Shaft/Axle (max)
Oil Drain Plug Front Differential/ Rear
Drive
Oil Fill Plug Front Differential/ Rear
Drive
Wheel (Steel) Hub
Wheel (Aluminum) Hub
Rear Drive Input Shaft/Housing Differential Housing
Rear Output Drive Flange Rear Yoke Flange
Shift Cam Stopper Shift Stopper
Shift Cam Plate Shift Cam Shaft
Shifter Housing Crankcase
Engine Output Shaft** Rear Gear Case Input
Flange
* w/Blue Loctite #243 ** w/Red Loctite #271
*** w/Green Loctite #609
Torque
Part Bolted To
ft-lb N-m
20 27
48 5.5
in.-lb
7 10
20 27
20 27
40 54
30 41
35 47
15 20
20 27
20 27
20 27
12 16
27
6 8
25 34
20 27
40 54
50 68
35 47
50 68
50 68
50 68
20 27
50 68
35 47
38 52
38 52
23 31
23 31
125 169
200 272
45 5
in.-lb
16 22
40 54
80 108
23 31
20 27
8 11
8 11
8 11
20 27