General Specifications (400 - Manual Transmission) - Arctic Cat 400 Service Manual

General Specifications*
(400 - Manual Transmission)
Type
Main Jet
Slow Jet
Pilot Screw Setting (turns)
Jet Needle
Idle RPM
(engine warm)
Starter Jet
Float Arm
Height
Throttle Cable Free-Play (at
lever)
Ignition Timing
Spark Plug
Type
Spark Plug Gap
Spark Plug Cap
Ignition Coil
Resistance
(secondary)
Ignition Coil
Peak Voltage
Magneto Coil
Resistance
(charging)
Magneto Coil
Peak Voltage
Stator Coil Out-
put
Magneto Output (approx)
Brake Type
Tire Size
Tire Inflation
Pressure
Back
CARBURETOR
Keihin CVK34
142 - VP
140 - FIS
38
1 3/8 - VP
1 1/8 - FIS
NAZG
1250-1350
75
17 mm (0.7 in.)
3-6 mm (1/8-1/4 in.)
ELECTRICAL
10° BTDC @ 1500 RPM
NGK CR7E
0.7-0.8 mm (0.028-0.032 in.)
8000-12,000 ohms
(primary) Less than 1 ohm
(terminal to ground)
5200-7800 ohms
(high tension - plug cap
removed - to ground)
(primary/ 250-375 volts
CDI) (terminal to ground)
(trigger) 160-240 ohms
(green to blue)
(source) Less than 1 ohm
(yellow to white)
Less than 1 ohm
(black to black)
(trigger) 5.04-7.56 volts
(green to blue)
(source) 0.7-1.05 volts
(yellow to white)
(no load) 60 AC volts @ 5000 RPM
(black to black #1)
(black to black #2)
220 W @ 5000 RPM
CHASSIS
Hydraulic w/Brake Lever
Lock and Auxiliary Brake
Front - 25 x 8-12
Rear - 25 x 10-12 - VP
Rear - 25 x 10-12 - FIS
0.35 kg/cm² (5 psi)
Back to TOC
MISCELLANY
Gas Tank Capacity (rated)
Reserve Capacity
Rear Drive Capacity
Differential Capacity (front -
4x4)
Engine Oil Capacity
Gasoline (recommended)
Engine Oil (recommended)
Differential/Rear Drive Lubricant
Brake Fluid
Taillight/Brakelight
Headlight
* Specifications subject to change without notice.
** One inch below filler plug threads.
*** At the oil level plug threads.
Back to Section TOC
17.98 L (4.75 U.S. gal.) -
VP
24.6 L (6.5 U.S. gal.) - FIS
2.46 L (0.65 U.S. gal.) - VP
275 ml (9.3 fl oz) - VP***
250 ml (8.5 fl oz) - FIS**
275 ml (9.3 fl oz) - VP**/
FIS***
3.08 L (3.25 U.S. qt)
87 Octane Regular
1
Unleaded
SAE 10W-40
SAE Approved
80W-90 Hypoid
DOT 4
12V/8W/27W
12V/37W (2)
Next
1-3