Club Car FE350 2005 Maintenance Service Supplement page 63

TROUBLESHOOTING AND ELECTRICAL SYSTEM
WAVETEK 5XL
V V
OFF
1000
500
200
200
20
200
2 2m
200
20
m
m
200
2000
m
k
200k
20k 200
2k
! ! 200nA
V COM
MAX
1000 ---
FUSED
750V
200 OHM SETTING
13. If a problem was not detected in the previous steps, check the following items:
• Battery voltage. See Test Procedure 1 – Battery on page 11-15.
• Continuity of all ground terminal block wires. See Test Procedure 10 – Wire Continuity on
page 11-24.
• Taillight sockets. See Test Procedure 36 – Taillight Bulb Socket on page 11-49.
• Check taillight bulbs for continuity.
• Brake pedal limit switch. See Test Procedure 39 – Brake Pedal Limit Switch on page 11-51.
• Park brake pedal limit switch. See Test Procedure 38 – Park Brake Limit Switch on page 11-51.
For Turf 2 vehicle:
• Check the continuity of the yellow wire from the inline fuse holder to the light switch.
• Check the continuity of the fuse in the inline fuse holder on the yellow wire connected to the large post
of the solenoid.
For Turf 6, Carryall 6, TransPorter, Villager 6, and Villager 8 vehicles:
• Check the continuity of the red wire from the fuse block to the large post of the solenoid.
• Check the continuity of the accessory fuse (located in the fuse block).
A
Some wires
removed for clarity.
Figure 11-50 Brake Light Relay Coil Test
2005 FE350 Gasoline Vehicle Maintenance and Service Supplement
10
11
Test Procedures
Page 11-47