Fuel Filters; General Information; Fuel Filter Removal; Fuel Filter Installation - Club Car FE350 2005 Maintenance Service Supplement

14
FUEL SYSTEM
Air Filter Replacement, Continued:
ý
CAUTION
• Engine damage will occur if the air box cover is not properly secured.
• If air box is extremely dirty, remove air box from vehicle and clean thoroughly.
• Use only Club Car replacement air filters (CCI P/N 1015426). The use of other air filters could
result in engine damage. If the air filter is too thin, the cover will seat before the filter can seal,
leaving space for dirt to pass into the engine on all sides of the element. This will damage the
engine and void the warranty.
7. Install hose (16) and hose clamp (15) (Figure 14-8, Page 14-13 or Figure 14-9, Page 14-14). Make
sure clamp ends are located in the 12:00 o'clock position.

FUEL FILTERS

See General Warning, Section 10, Page 10-1.

GENERAL INFORMATION

Fuel is supplied to the fuel pump and carburetor through flexible lines. Two in-line filters are installed between
the fuel tank and the carburetor (Figure 14-11, Page 14-19). Fuel filters, fuel lines, and the fuel tank vent
should be inspected periodically for leaks.
The fuel filters should be replaced when necessary, but under no circumstance should the period of time
between filter changes exceed two years or 200 hours.

FUEL FILTER REMOVAL

1. Turn the key switch to the OFF position and remove the key, place the Forward/Reverse handle in the
NEUTRAL position, and chock the wheels.
2. Disconnect the battery cables as instructed. See WARNING "To avoid unintentionally starting..." in
General Warning, Section 10, Page 10-1.
3. To prevent fuel drainage, turn the fuel shut-off valve (15) (Figure 14-11, Page 14-19) on the fuel tank to
the closed (OFF) position (Figure 14-16, Page 14-27).
4. Remove the primary fuel filter (17) (Figure 14-11, Page 14-19).
4.1. Remove the clamps (16) and fuel lines (1 and 2) from the filter and plug the fuel lines.
5. Remove the secondary filter (22).
5.1. Remove the clamps (16 and 20) and fuel lines (3 and 4) from the filter and plug the fuel lines
(3 and 4).

FUEL FILTER INSTALLATION

ý
CAUTION
• Fuel filters are marked with flow direction arrows. Make sure that filters are installed with
arrows pointing in the direction of fuel flow from tank to carburetor.
Page 14-18 2005 FE350 Gasoline Vehicle Maintenance and Service Supplement
Fuel Filters