Honda Civic Service Manual page 95

4 0 . I n s t a l l t h e a i r c l e a n e r h o u s i n q .
6 x 1 . 0 m m
12 N m (1.2 kgf.m,8.7 lbt.ft)
I n s t a l l t h e a i r c l e a n e r h o u s i n g c o v e r ( A ) a n d
connect the intake air temperature (lAT) sensor
connector (B),
4 2 . I n s t a l l t h e b r e a t h e r h o s e ( C ) a n d v a c u u m h o s e 1 D ) .
4 1 .
4 3 . I n s t a l l t h e i n t a k e m a n i f o l d c o v e r .
6 x 1 . 0 m m
1 2 N m 1 1 . 2 k g f . m .
8.7 tbf.ft)
Installthe battery. Clean the battery posts and
c a b l e t e r m i n a l s w i t h s a n d p a p e r , t h e n a s s e m b l e
them and apply grease to prevent corrosion.
Check that the transmission shifts into gear
smoothly.
Inspect for fuel leaks. Turn the ignition switch ON
(ll) {do not operate the starter) so that the fuel pump
runs for about 2 seconds and pressurizes the fuel
line. Repeat this operation two or three times, then
check for fuel leakage at any point in the fuel line.
R e f i l l t h e e n g i n e w i t h e n g i n e o i l ( s e e p a g e 8 - 5 ) .
R e f i l l t h e t r a n s m i s s i o n w i t h f l u i d ( s e e p a g e 1 3 - 3 ) .
Refill the radiator with engine coolant, and bleed
air from the cooling system with the heater valve
o p e n ( s e e p a g e 1 0 - 6 ) .
P e r f o r m t h e e n g i n e c o n t r o l m o d u l e ( E C M ) i d l e l e a r n
p r o c e d u r e ( s e e p a g e 1 1 - 1 3 9 ) .
Inspect the idle speed (see page 1 1-138).
I n s p e c t t h e i g n i t i o n t i m i n g ( s e e p a g e 4 - 1 7 ) .
C h e c k t h e w h e e l a l i g n m e n t { s e e p a g e 1 8 - 4 ) .
Enter the anti-theft code for the radio, then enter
the customer's radio station presets.
Set the clock.
Y
E
44.
41.
] t E
46.
48.
4 9 .
52.
5 3 .
54.
5 0 .
5 1 .
55.
5 - 1 5