Table of Contents
Advertisement
© Mitsubishi Forklift Trucks 2013. All
© Mitsubishi Forklift Trucks 2013. All
PBV20N2
PBV20N2
standard EN 1987 part 1. The insulation resistance of the battery must not fall below the
standard EN 1987 part 1. The insulation resistance of the
value of 50 Ω per Volt of nominal voltage, in compliance with the standard EN 50272
value of 50
Ω per Volt of nominal voltage, in compliance with the standard EN 50272 -3.
For batteries up to 20 V nominal voltage, the minimum value is 1000 Ω.
For batteries up to 20 V nominal voltage, the minimum value is 1000
For batteries fitted with an electrolyte circulation system, check the filter of the
For batteries fitted with an electrolyte circulation system, check
and clean or replace it, if needed. The filter may need to be replaced earlier than
and clean or replace it, if
needed. The filter may need to be replaced earlier than
expected if there are no leaks
expected if there are no leaks in the air pipes but
the air mixing system on the charger or on the battery (on the DC air pump or remote
the air mixing system on the charger or on the battery (on the DC air pump or r
signal) is
signal) is illuminate
illuminated. d.
During annual maintenance, also check the correct operation of the air pump.
During annual maintenance, also check the correct operation of the air pump.
7.3
7.3
Recharging the battery
Recharging the battery
Make sure that the charger is the
Make sure that the charger is the appropriate model (correct battery type and voltage)
and that the battery has sufficient ventilation.
and that the battery has sufficient ventilation.
1. 1. Park the truck in
Park the truck in a reserved recharging place.
a reserved recharging place.
2. 2. Switch the truck's power off.
Switch the truck's power off.
3. 3. Make sure that the charger has
Make sure that the charger has
been switched off.
been switched off.
4. 4. Open the battery cover. For instructions, see the
Open the battery cover. For instructions, see the section
5. 5. Disconnect the battery connector
Disconnect the battery connector
and connect it to the charger.
and connect it to the charger.
https://www.forkliftpdfmanuals.com/
rights reserved.
rights
reserved.
Revision: B
Revision: B
in the air pipes but for some reason the defect signal of
for some reason the defect signal of
CAUTION
CAUTION
appropriate model (correct battery type and voltage)
Document ID: 615023
Document ID: 615023
Service Manual
Service
Manual
battery must not fall below the
Ω.
the filter of the air pump
air pump
emote
section 5.4.4.
5.4.4.
80 (244)
80 (244)
-3.
Advertisement
Table of Contents
