General; Procedures; Air Filter; Air Filter Housing - BRP BOMBARDIER DS250 2006 Shop Manual

Section 03 ENGINE
Subsection 03 (AIR INTAKE SYSTEM)

GENERAL

If vehicle is used in dusty area, inspect more fre-
quently than specified in maintenance chart.
CAUTION: Do not start engine when liquid or
deposits are found in the drain tube. If you
have oil in the air filter housing, check engine
oil level. Maybe oil level is too high.
CAUTION: Never remove or modify any com-
ponent in the air filter housing. Otherwise, en-
gine performance degradation or damage can
occur. The engine carburetion is calibrated to
operate specifically with these components.
Disconnect battery before working on fuel sys-
tem.
WARNING
Always disconnect battery exactly in the
specified order, BLACK (-) cable first. It is
recommended to disconnect electrical con-
nections prior to disconnecting fuel lines.

PROCEDURES

AIR FILTER

Removal
NOTE: When replacing air filter, clean or replace
the air injection valve filters at the same time.
Remove seat.
Release clamps and remove air filter housing cov-
er.
vmo2006-014-045_a
1. Air filter housing cover
Loosen clamp and remove retaining screw, then
remove air filter.
34
vmo2006-014-046_a
1. Clamp
2. Retaining screw
CAUTION: Engine performance degradation or
severe damages can occur if the air filter is not
properly maintained and/or if it not well oiled.
Cleaning
Pour cleaning solution (P/N 219 700 341) or an
equivalent into a bucket. Put the filter in to soak.
While filter soaks, clean inside of air filter housing.
Rinse the filter with warm water until all cleaning
solution disappears.
NOTE: If the air filter foam is still dirty, replace it
with a new one.
Then, let the filter dry completely.
When the filter is dried, re-oiled with air filter oil
(P/N 219 700 340) or an equivalent.
Installation
Properly reinstall removed parts in the reverse or-
der of their removal.
NOTE: Make sure that air filter housing cover is
installed properly.

AIR FILTER HOUSING

Draining
Periodically inspect air filter housing drain tube for
liquid or deposits.
vmr2006-068