an error in the PoI2 shut-off [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 238

DTC 4E3-12-Level 2 Monitoring : Diagnosis fault check to report the error to demand for an ICO due to

an error in the PoI3 efficiency factor [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 239

DTC 52C-01-Glow Control Unit (GCU) data error [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 240

DTC 532-03-Engine coolant temperature has exceeded the warning threshold [ECU] . . . . . . . . . . . . . . 242

DTC 535-03-Maximum rail pressure exceeded [ECU]. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 243

DTC 54C-03-Engine over speed condition detected [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 244

DTC 559-12-Fuel metering unit has an over-temperature error [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . 245

DTC 58C-03-Throttle valve actuator will not open to commanded position [ECU] . . . . . . . . . . . . . . . . . . 247

DTC 58C-04-Throttle valve actuator will not close to commanded position [ECU] . . . . . . . . . . . . . . . . . . 248

DTC 58D-03-Throttle valve actuator control circuit high side shorted to battery [ECU] . . . . . . . . . . . . . . 249

DTC 58D-04-Throttle valve actuator control circuit high side shorted to ground [ECU] . . . . . . . . . . . . . . 251

DTC 5D2-03-ECU internal failure - EEPROM memory failure [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 253

DTC 5D4-02-ECU internal failure - WDA is not working correctly [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . 254

DTC 5D4-03-ECU internal failure - Alarm task period error [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 255

DTC 5D4-04-ECU internal failure - Positive test failed [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256

DTC 5D4-12-ECU internal failure - Timeout in the shut off path test error [ECU] . . . . . . . . . . . . . . . . . . . 257

DTC 5E3-03-ECU internal failure - Torque request due to fuel pressure exceeds maximum torque limit

[ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 258

DTC 5E3-04-ECU internal failure - Torque request due to air control exceeds maximum torque limit

[ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259

DTC 5E3-12-ECU internal failure - Torque request exceeds maximum torque limit [ECU] . . . . . . . . . . . 260

DTC 601-02-Lambda sensor nernst cell open circuit [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 261

DTC 602-02-Lambda sensor pump current open circuit [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 263

DTC 605-03-Lambda sensor O2 value above maximum threshold [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . 265

DTC 606-02-Lambda sensor virtual ground open circuit [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 267

DTC 607-03-Lambda sensor O2 calibrator too high error [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 269

DTC 607-04-Lambda sensor O2 calibrator too low error [ECU]. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 270

DTC 609-02-ECU internal failure - SPI chip error configuration [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . 271

DTC 60A-04-Lambda sensor heater battery voltage too low [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 272

DTC 60B-03-Lambda sensor cell circuits short circuit to battery [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . 274

DTC 60B-04-Lambda sensor cell circuits short circuit to ground [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . 276

DTC 60C-03-Lambda sensor estimated temperature higher than threshold [ECU] . . . . . . . . . . . . . . . . . 278

DTC 60C-04-Lambda sensor estimated temperature lower than threshold [ECU] . . . . . . . . . . . . . . . . . . 280

DTC 68D-03-Throttle valve actuator control circuit low side shorted to battery [ECU]. . . . . . . . . . . . . . . 282

DTC 68D-04-Throttle valve actuator control circuit low side shorted to ground [ECU]. . . . . . . . . . . . . . . 284

DTC 6D4-02-ECU internal failure - 'WDA active' reported due to errors in query/response communication

[ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 286

DTC 6D4-03-ECU internal failure - 'ABE active' reported due to overvoltage detection [ECU] . . . . . . . 287

DTC 6D4-04-ECU internal failure - 'ABE active' reported due to undervoltage detection [ECU] . . . . . . 288

DTC 6D4-12-ECU internal failure - 'WDA/ABE active' reported [ECU] . . . . . . . . . . . . . . . . . . . . . . . . . . . . 289

DTC 72C-00-Glow plug 1 control circuit shorted to ground [ECU]. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 290

DTC 72C-01-Glow plug 3 control circuit shorted to ground [ECU]. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 292

47866583_ 02/12/2015

55.12 [55.DTC] / 6

Table of Contents