1982 Jeep Engine Maintenance - Jeep J-10 Series 1982 Technical & Service Manual

MAINTENANCE B-3
1982 JEEP ENGINE MAINTENANCE
MUas (Thousands)
KDomatara (Thousands)
Mentha
Each
Fuel
FBI
12.5 20 27.5 39 3?. 42£ 60
20 32
44
48
64
69 80
12.6
20 27.5
30
35
42.5
50
1) Chock Engine Oil Laval
•
2) Change Engine Oil
• •
c
•
3) Change Engine Oil Fitter (4-Cytinder California)
♦ ♦
©
♦
3) Change Engine Oil Fitter (Except 4-CyltnderCalifornia)
• • •
4) Check Automatic Transmission Fluid
• • •
5) Check Battery
• • •
6) Check Brake Master Cylinder Fluid Level
• e •
7) Check Coding System Fluid Level
•
e •
7) Drain and Change Coolant®
o
8) Check Hydraulic Clutch Reservoir Fluid Laval
e •
8) Check Power Steering Pump Fluid Laval
a e
9) Check Drive Belt Tension
♦
•
♦
9) Check Drive Beit Tension (8-Cyl.)
• e •
10) Replace Fuel filter (4-and 6-Cyl.)
♦
♦
♦
10) Replace Fuel filter (8-Cyl.)
• •
•
11) Lubricate Exhaust Heat Valve (8-Cylinder only)
0
•
c
0
12) Replace Air Cleaner Filter®
13) Replace PCV Filter 14-Cylinder California)
13) Clean PCV fitter (8- 6- and 4-Cylinder except 4-Cyt.California )<3>
14) Replace PCV Valve
♦
14) Replace PCV Valve (8-Cyl.)
•
14) Inspect PCV Hoses and Connections
$
14) Inspect PCV Hoses and Connections (B-Cytinder)
e
15) Tune Up
HI
e
Check and Adjust Curb and Fast Idle Speed •
— • -
Check and Adjust Curb and Fast Idle Speed (8-Cytinder)
Check Distributor Vacuum and Centrifugal Advance Mechanism
♦
Check Distributor Vacuum and Centrifugal Advance Mechanism (8-Cvltnder)
•
_ - . -
Check Distributor Cap and Rotor
0
if
*
Check Distributor Cap and Rotor (8-Cyt.)
Check and Adjust Carburetor Mounting Bolts (4-Cylinder)
•
Clean Choke System
* i
Check TAC Control System
a
Check TAC Control System (8-Cyl.)
9
Check Fuel System, Filler Cap. Tank, Lines. Hoses and Connections
•
Check Air System Hoses (8-Cylinder)
Check Vacuum Fittings, Hoses and Connections
J
f
«
Check Vacuum fittings. Hoses and Connections (8-Cyl.)
Check Coil and Spark Plug Wires
♦
•
e
Check Coil and Spark Plug Wires (8-Cyl.)
♦
Check Exhaust System
•
• •
• Required f Recommended, But Not Required
® Change coolant Initially at 12.600 mi (20 000 km) or 12% months, whichever comas first, than at tha start of each wintar saason. Maintain a 60/50 mixture of
coolant and watar (-34°F/ -38°C Fraating Point) for cooting aystam corroaion protection during tha summer saason.
* Raplaca air ciaansr alamant once In between each normally achadulad changa under heavy duty driving conditions - partlculaily OiiAuy iHvc'ornifiamiy c.-, ('.••. ;-,-
roads.
® On 6-Cyflnder models, dean PCVfilter in aircleaner. On 8-Cytlnder models, dean PCVfilter In oil fillercap.