Suzuki SY413 Service Manual page 2370

WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System:
Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "Air Bag System Components and Wiring Location View" un-
der "General Description" in air bag system section in order to confirm whether you are perform-
ing service on or near the air bag system components or wiring. Please observe all WARNINGS
and "Service Precautions" under "On-Vehicle Service" in air bag system section before perform-
ing service on or around the air bag system components or wiring. Failure to follow WARNINGS
could result in unintentional activation of the system or could render the system inoperative. Ei-
ther of these two conditions may result in severe injury.
Technical service work must be started at least 90 seconds after the ignition switch is turned to
the "LOCK" position and the negative cable is disconnected from the battery. Otherwise, the sys-
tem may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
ON-VEHICLE SERVICE . . . . . . . . . . . . . . . . . . . .
FRONT DOOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Window Regulator
Front Door Lock . . . . . . . . . . . . . . . . . . . . . . . . .
Front Door Assembly . . . . . . . . . . . . . . . . . . . . .
REAR DOOR (For Sedan Model)
Door Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Door Window Regulator
Rear Door Lock . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Door Assembly . . . . . . . . . . . . . . . . . . . . .
BACK DOOR
(For Hatch-back and Wagon Models)
Back Door Balancer . . . . . . . . . . . . . . . . . . . . . .
WINDSHIELD . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
REAR QUARTER WINDOW
(For Hatch-back and Wagon Models)
BACK WINDOW (For Sedan Model)
BACK DOOR GLASS
(For Hatch-back and Wagon Models)
TRUNK LID (For Sedan Model)
HOOD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
FRONT FENDER . . . . . . . . . . . . . . . . . . . . . . . . . .
SECTION 9
BODY SERVICE
CONTENTS
9- 2
9- 2
9- 2
. . . . . . . . . . . . . . . . . . 9- 4
9- 5
9- 7
. . . . . . . . . . . . 9- 8
9- 8
. . . . . . . . . . . . . . . . . . 9-10
9-11
9-11
. . . . . . . 9-12
9-14
9-15
. . . . . . . 9-21
. . . . . . . . . 9-26
. . . . . . . 9-30
. . . . . . . . . . . . . 9-35
9-37
9-38
BUMPERS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Bumper . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Bumper . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Bumper Lower Extension (If Equipped) 9-43
Rear Bumper Lower Extension (If Equipped)
SIDE MOLDINGS . . . . . . . . . . . . . . . . . . . . . . . . . .
SPLASH GUARD . . . . . . . . . . . . . . . . . . . . . . . . . .
REAR SPOILER (If Equipped)
ROOF RAIL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SEATS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rear Seat Cushion . . . . . . . . . . . . . . . . . . . . . . .
Rear Seatback . . . . . . . . . . . . . . . . . . . . . . . . . .
SEAT BELTS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Seat Belt Pretensioner (If Equipped)
FLOOR CARPET . . . . . . . . . . . . . . . . . . . . . . . . . .
Front Floor Carpet . . . . . . . . . . . . . . . . . . . . . . .
Luggage Floor Carpet . . . . . . . . . . . . . . . . . . . .
REAR SPEAKER COVER
ROOF LINING . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SLIDING ROOF . . . . . . . . . . . . . . . . . . . . . . . . . . . .
INSTRUMENT PANEL . . . . . . . . . . . . . . . . . . . . . .
BODY SERVICE 9-1
9-39
9-39
9-40
9-44
9-45
9-46
. . . . . . . . . . . . . . 9-47
9-48
9-49
9-49
9-50
9-50
9-51
9-52
. . . . . . . . 9-55
9-58
9-58
9-59
. . . . . . . . . . . . . . . . . . 9-60
9-61
9-63
9-67
9