Suzuki SY413 Service Manual page 2577

WARNING:
For vehicles equipped with Supplement Restraint (Air Bag) System:
D Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "Air Bag System Components and Wiring Location View" un-
der "General Description" in air bag system section in order to confirm whether you are perform-
ing service on or near the air bag system components or wiring. Please observe all WARNINGS
and "Service Precautions" under "On-Vehicle Service" in air bag system section before perform-
ing service on or around the air bag system components or wiring. Failure to follow WARNINGS
could result in unintentional activation of the system or could render the system inoperative. Ei-
ther of these two conditions may result in severe injury.
D Technical service work must be started at least 90 seconds after the ignition switch is turned to
the "LOCK" position and the negative cable is disconnected from the battery. Otherwise, the sys-
tem may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
NOTE:
D According the vehicle specification (engine type and whether WU TWC equipped or not), the reference
section is different.
Confirm the vehicle specification referring to "IDENTIFICATION INFORMATION" in Section 0A and refer
to the applicable section.
D Wether the following systems (parts) are used in the particular vehicle or not depends on vehicle specifi-
cations. Be sure to bear this in mind when performing service work.
– EGR valve/heated oxygen sensor or CO adjusting resistor/three-way catalytic converter (TWC)
– Heated oxygen sensor-2 (HO2S-2)/CKP sensor/Warm up three way catalytic converter (WU TWC)
ENGINE (Engine Without WU TWC)
ENGINE GENERAL INFORMATION AND DIAGNOSIS (G13/G16 Engine With WU TWC)
ENGINE GENERAL INFORMATION AND DIAGNOSIS (J18 Engine With WU TWC)
ENGINE MECHANICAL (G13/G16 Engine)
ENGINE MECHANICAL (J18 Engine)
ENGINE COOLING (G13/G16 Engine)
ENGINE COOLING (J18 Engine)
ENGINE FUEL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ELECTRONIC FUEL INJECTION SYSTEM (G13/G16 Engine Without WU TWC)
ENGINE AND EMISSION CONTROL SYSTEM (G13/G16 Engine With WU TWC)
ELECTRONIC FUEL INJECTION SYSTEM (J18 Engine Without WU TWC)
ENGINE AND EMISSION CONTROL SYSTEM (J18 Engine With WU TWC)
IGNITION SYSTEM (G13/G16 Engine)
IGNITION SYSTEM (J18 Engine)
CRANKING SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Section 6
ENGINE
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ENGINE (ENGINE WITHOUT WU TWC) 6-1
. . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
6
6-1
6-1-1
6-2-1
6A1-1
6A3-1
6B-1
6B1-1
6C-1
6E1-1
6E2-1
6E3-1
6E4-1
6F1-1
6F2-1
6G-1