Table of Contents
Advertisement
Up/Down adjustment are to be
NOTE: Forward/Rearward and
MEASUREMENT LOCATIONS
FORWARD/REARWARD
made at the same time.
AND THEIR VALUES
ADJUSTMENT
SECTION C-C
SECTION A-A
SECTION B-B
SEQUENCE
UP/DOWN
IN/OUT
23 - 56
BODY
ADJUSTMENTS (Continued)
DOOR GLASS ALIGNMENT VERIFICATION
NOTE: Door Glass Alignment Verification procedure
must be done whenever the door glass is adjusted
and after all adjustments are made.
(1) Raise quarter glass to full up position.
(2) Close door and cycle door glass between full up
and full down positions.
(3) Verify that door glass operates smoothly and
maintains correct alignment to convertible top and
quarter glass.
(4) Verify that quarter glass weatherstrip fully
contacts door glass.
(5) Verify that no scissoring of the door glass and
weatherstrip occurs.
(6) If any of the above conditions are found,
(a) Adjust quarter glass. Refer to Quarter Glass
Adjustment procedures found in this section.
(b) Re–adjust the door glass as necessary to cure
the condition.
QUARTER GLASS ADJUSTMENT
NOTE: The door glass must be properly adjusted
prior to performing any quarter glass adjustments.
UP-STOP ADJUSTMENTS
from side rail weatherstrip retainer channels.
erstrip retainer gap (Fig. 82).
to side rail weatherstrip retainer channels.
down positions. Verify operation and re-adjust as nec-
essary.
beneath the lip of the weatherstrip.
TOP OF GLASS—INBOARD/OUTBOARD
ADJUSTMENTS
from side rail weatherstrip retainer channels.
screw jam-nuts.
ADJUSTMENT SPECIFICATIONS
Fig. 82
(1) Remove quarter trim panel.
(2) Remove center and rear side rail weatherstrips
(3) Loosen up-stop nuts.
(4) Raise quarter glass.
(5) Slide up-stop to achieve proper glass to weath-
(6) Tighten all fasteners.
(7) Install center and rear side rail weatherstrips
(8) Cycle quarter glass between full up and full
(9) Verify that the top edge of the door glass is
(10) Install quarter trim panel.
(1) Remove quarter trim panel.
(2) Remove center and rear side rail weatherstrips
(3) Using a suitable wrench, loosen the lower jack-
(4) Raise quarter glass.
JX
Advertisement
Chapters
Table of Contents
