Table of Contents
Advertisement
CHASSIS / BODY ELECTRICAL
BATTERY SERVICE
BATTERY SPECIFICATIONS
BATTERY PN 4014043 / 4014132-P
Type
Polaris Maintenance Free
Voltage
12 VDC
Nominal Capacity
32 AH
@ 20 HR Rate
CCA
575 CCA
Nominal Open
12.8 VDC
Circuit Voltage
Recommended
1.8A @ 5-10 HR or 6.0A @ 1
Charging Rate
HR
Never attempt to open the battery.
12.30
CAUTION
GENERAL BATTERY INFORMATION
CALIFORNIA PROPOSITION 65 WARNING:Batteries,
battery posts, terminals and related accessories contain
lead and lead compounds, and other chemicals known
to the State of California to cause cancer and birth
defects or other reproductive harm. WASH HANDS
AFTER HANDLING.
Battery electrolyte is poisonous. It contains acid!
Serious burns can result from contact with the skin,
eyes, or clothing.ANTIDOTE:External: Flush with water.
Internal: Drink large quantities of water or milk. Follow
with milk of magnesia, beaten egg, or vegetable oil. Call
a physician immediately.Eyes: Flush with water for 15
minutes and get prompt medical attention.Batteries
produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using
in closed space. Always shield eyes when working near
batteries.Keep out of reach of children.
1. Check battery voltage with a volt/ohm meter. A fully
charged battery should be 12.8 V or higher.
2. If the voltage is below 12.6 V, the battery will need to
be recharged.
To service a Maintenance Free battery:
1. Remove battery from the vehicle.
2. Test battery with a voltage meter or load tester to
determine battery condition. This will determine the
length of time required to charge the battery to full
capacity.
3. Charge the battery as recommended.
BATTERY TERMINAL BLOCK
q
The terminal block
is located under the hood. The
terminal block provides easy hookup for accessories.
9850045 R01 - 2020-2021 RANGER 1000 Service Manual
WARNING
WARNING
© Copyright Polaris Inc.
Advertisement
Chapters
Table of Contents
Troubleshooting
