Battery Service; Battery Specifications; General Battery Information - Polaris RANGER XP 900 2018-2019 Service Manual

BATTERY SERVICE

BATTERY SPECIFICATIONS

Battery PN 4014043 / 4014132-P
Type
Polaris Maintenance Free
Voltage
12 Vdc
Nominal Capacity
32 AH
@ 20 HR Rate
CCA Johnson Controls - 575
Nominal Open
12.8 Vdc or more.
Circuit Voltage
Recommended
1.8A @ 5-10 HR or 6.0A @ 1
Charging Rate
HR
CAUTION
Never attempt to open the battery.
9929399 R01 - 2018-2019 RANGER XP/ CREW 900/1000 Service Manual
© Copyright Polaris Industries Inc.

GENERAL BATTERY INFORMATION

WARNING
CALIFORNIA PROPOSITION 65 WARNING:Batteries,
battery posts, terminals and related accessories contain
lead and lead compounds, and other chemicals known
to the State of California to cause cancer and birth
defects or other reproductive harm. WASH HANDS
AFTER HANDLING.
WARNING
Battery electrolyte is poisonous. It contains acid!
Serious burns can result from contact with the skin,
eyes, or clothing.ANTIDOTE:External: Flush with water.
Internal: Drink large quantities of water or milk. Follow
with milk of magnesia, beaten egg, or vegetable oil. Call
a physician immediately.Eyes: Flush with water for 15
minutes and get prompt medical attention.Batteries
produce explosive gases. Keep sparks, flame,
cigarettes, etc. away. Ventilate when charging or using
in closed space. Always shield eyes when working near
batteries.Keep out of reach of children.
1. Check battery voltage with a volt/ohm meter. A fully
charged battery should be 12.8 V or higher.
2. If the voltage is below 12.6 V, the battery will need to
be recharged. Refer
Procedure"page 11.45.
To service a Maintenance Free battery:
3. Remove battery from the vehicle. Refer to "Battery
Removal"page 2.39 procedure.
4. Test battery with a voltage meter or load tester to
determine battery condition. This will determine the
length of time required to charge the battery to full
capacity. Refer to "OCV - Open Circuit Voltage
Test"page 11.44 procedure.
5. Charge the battery as recommended. Refer to
"Battery Charging Procedure"page 11.45.
ELECTRICAL
to "Battery Charging
11
11.43