Gearbox Lubrication - MOTO GUZZI California EV Workshop Manual

A
B
C
D
E
F
G
H
I
L
M
N
O
P
18
B
A
C
G
EARBOX LUBRICATION
Every 5000 km (3000 mi)check that the oil almost reaches
the hole in oil level plug "A".
Carry out the test with the vehicle in a perfectly vertical
position and when the engine is hot; an incorrect position
could cause a wrong the reading.
If the oil lies beneath this level, top up with the required
oil indicated in the table in section B chapter 2 pouring it
in through the hole "B".
About every 10000 km (6000 mi), it is necessary to
replace the oil. This must be carried out when the engine
is warm to allow the oil to drain more quickly and
thoroughly. To bring it to temperature, followed the
operations under listed:
• Place a pan under the gearbox to collect the used oil;
• Remove the oil filler cap "B" to let the oil drain more
quickly;
• Unscrew the oil-draining plug "C" and let all the gearbox
oil flow out;
• Screw-down the oil draining plug once again and
tighten it to the torque prescribed in the table, section
B, chapter 4;
• Unscrew oil level plug "A";
• Pour in the new oil indicated in the table of section B
chapter 2 through the special hole until the level almost
reaches the hole in the oil level plug "A".
• Refit and tighten the oil level plug "A" and the oil filler
cap "B"
S
CHEDULED
M
AINTENANCE