Suzuki WagonR+ RB310 Service Manual page 1268

BRAKES PIPE/HOSE/MASTER CYLINDER
WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System:
• Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "Air Bag System Components and Wiring Location View" under
"General Description" in air bag system section in order to confirm whether you are performing ser-
vice on or near the air bag system components or wiring. Please observe all WARNINGS and "Ser-
vice Precautions" under "On-Vehicle Service" in air bag system section before performing service
on or around the air bag system components or wiring. Failure to follow WARNINGS could result in
unintentional activation of the system or could render the system inoperative. Either of these two
conditions may result in severe injury.
• Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system
may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
NOTE:
All brake fasteners are important attaching parts in that they could affect the performance of vital
parts and systems, and/or could result in major repair expense. They must be replaced with one of
same part number or with an equivalent part if replacement becomes necessary. Do not use a replace-
ment part of lesser quality or substitute design. Torque values must be used as specified during reas-
sembly to assure proper retention of all parts. There is to be no welding as it may result in extensive
damage and weakening of the metal.
For the items with asterisk (*) in the "CONTENTS" below, refer to the same section of the Service Man-
ual mentioned in FOREWORD of this manual.
General Description.............................................. *
LSPV (Load Sensing Proportioning Valve)
Assembly (if equipped)........................................ *
Diagnosis............................................................... *
Check and Adjustment ......................................... *
On-Vehicle Service..........................................5A-2
Front Brake Hose/Pipe..................................5A-2
Rear Brake Hose/Pipe ........................................ *
SECTION 5A
10
8A
8B
8C
8D
5BE
9
10
10A
10B
CONTENTS
Master Cylinder Reservoir .................................. *
Master Cylinder Assembly .................................. *
Brake Booster ..................................................... *
LSPV (Load Sensing Proportioning Valve)
Assembly (if equipped) ....................................... *
Brake Pedal and Brake Pedal Blacket ................ *
Required Service Material .................................... *
Special Tools......................................................... *
BRAKES PIPE/HOSE/MASTER CYLINDER 5A-1
5A
5B