Suzuki WagonR+ RB310 Service Manual page 966

WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System :
• Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to "System Components and Wiring Location View" under "Gen-
eral Description" in Section 10B in order to confirm whether you are performing service on or near
the air bag system components or wiring. Please observe all WARNINGS and "Service Precautions"
under "On-Vehicle Service" in Section 10B before performing service on or around the air bag sys-
tem components or wiring. Failure to follow WARNINGS could result in unintentional activation of
the system or could render the system inoperative. Either of these two conditions may result in
severe injury.
• Technical service work must be started at least 90 seconds after the ignition switch is turned to the
"LOCK" position and the negative cable is disconnected from the battery. Otherwise, the system
may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
General Description......................................7B1-3
Specifications ..............................................7B1-5
Clutch/Brake/Planetary Gear ......................7B1-6
Functions.................................................7B1-6
Table of Component Operation...................7B1-7
Electronic Shift Control System...................7B1-8
Transmission Control Module
(TCM) ........................................................7B1-10
Operation of shift solenoid valves,
timing solenoid valve and TCC
solenoid valve........................................7B1-11
Automatic gear shift diagram.................7B1-12
Diagnosis.....................................................7B1-13
General Description ..................................7B1-13
On-board Diagnostic System ....................7B1-14
Precaution in Diagnosing Trouble .............7B1-15
Automatic Transaxle Diagnostic
Flow Table.................................................7B1-16
"O/D OFF" Lamp Check ............................7B1-20
Malfunction Indicator Lamp (MIL)
Check ........................................................7B1-20
Diagnostic Trouble Code (DTC)
Check ........................................................7B1-20
Diagnostic Trouble Code (DTC)
Clearance..................................................7B1-21
Diagnostic Trouble Code (DTC) Table......7B1-22
Fail Safe Table ..........................................7B1-24
Visual Inspection .......................................7B1-26
Automatic Transaxle Basic Check.............7B1-27
SECTION 7B1
AUTOMATIC TRANSAXLE
(M13 ENGINE MODEL)
CONTENTS
AUTOMATIC TRANSAXLE (M13 ENGINE MODEL) 7B1-1
Trouble Diagnosis Table ........................... 7B1-28
Trouble diagnosis table-1...................... 7B1-28
Trouble diagnosis table-2...................... 7B1-31
Trouble diagnosis table-3...................... 7B1-33
Road Test ................................................. 7B1-34
Manual Road Test..................................... 7B1-37
Engine Brake Test .................................... 7B1-38
Stall Test ................................................... 7B1-39
Time Lag Test ........................................... 7B1-40
Line Pressure Test.................................... 7B1-41
"P" Range Test.......................................... 7B1-42
Diagnostic Flow Table A-1: No
Gear Shift to O/D ...................................... 7B1-43
Diagnostic Flow Table A-2: No
Lock-Up Occurs ........................................ 7B1-44
Diagnostic Flow Table A-3: "O/D
OFF" Lamp Circuit Check ("O/D
OFF" Lamp Lights Steadily) ...................... 7B1-45
Diagnostic Flow Table A-4: "O/D
OFF" Lamp Circuit Check ("O/D OFF"
Lamp Does Not Light Anytime) ................. 7B1-47
Diagnostic Flow Table A-5: TCM
Power and Ground Circuit Check ............. 7B1-48
DTC P0705 Transmission
Range Sensor Circuit Malfunction ............ 7B1-50
DTC P0707 Transmission Range
Sensor Circuit Low.................................... 7B1-53
DTC P0712 Transmission Fluid
Temperature Sensor Circuit Low .............. 7B1-56
6E2
6F2
6G
6H
6K2
7A2
7B1
7C
7D
7F
8B
8C
8G
8G3
9