Brake Hoses; Tires - HYOSUNG TE 450 Service Manual

BRAKE HOSES

Inspect Interval
Inspect Every 6 months.
Replace Every 4 years.
Check the brake hoses for leakage, crack, wear and
damage.
If any damages are found, replace the brake hoses
with new ones.

TIRES

Inspect Interval
Inspect Every 3 months.
▣ ▣ TIRE TREAD CONDITION
Operating the vehicle with excessively worn tires will
decrease riding stability and consequently invite a
dangerous situation. It is highly recommended to
replace a tire when the remaining depth of the tire
tread reaches the following specification.
Front and rear
tire tread depth
▣ ▣ TIRE PRESSURE
If the tire pressure is too high or too low, steering will
be adversely affected and tire wear will increase.
Therefore, maintain the correct tire pressure for good
roadability and a longer tire life.
Cold inflation tire pressure is as follows.
COLD INFLATION TIRE PRESSURE
ONE PERSON
0.3 kgf/cm
FRONT 30 kPa
4.4 psi
0.3 kgf/cm
REAR
30 kPa
4.4 psi
※ ※ VEHICLE LOAD CAPACITY LIMIT : 150 kg (330.7 lbs)
Service limit
4 mm (0.16 in)
TWO PERSONS
2 2
0.35 kgf/cm
35 kPa
4.9 psi
2
2
0.35 kgf/cm
35 kPa
4.9 psi
PERIODIC MAINTENANCE 2-18
CAUTION
To minimize the possibility of tire damage from
over-inflation, we strongly recommended that a
manual type air pump be used rather than a high
pressure air compressor as found in service sta-
tions. When filling air into the tires, never exceed
2
250 kPa (2.5 kgf/cm , 36 psi).
CAUTION
The standard tire fitted on this vehicle is
a 21× × 7-10 for the front and
a 20× × 11-9 for the rear.
The use of tires other than those specified may
cause instability. It is highly recommended to use
the specified tires.