Engine Coolant - HYOSUNG TE 450 Service Manual

ENGINE COOLANT

Inspect Interval
Replace Every 2 years.
▣ ▣ ENGINE COOLANT CHECK
● Check the engine coolant level by observing the
upper � and lower � lines on the engine coolant
reservoir tank.
● If the level is below the lower line, add engine
coolant until the level reaches the upper line.
▣ ▣ ENGINE COOLANT REPLACEMENT
● Remove the radiator cap ①
reservoir tank cap ② .
● Place a pan below the water pump, and then drain
the engine coolant by removing the drain bolt ③ .
WARNING
� � Do not open the radiator cap when the engine
is hot, as you may be injured by escaping hot
liquid or vapor.
� � Engine coolant may be harmful if swallowed or
if it comes in contact with the skin or eyes. If
engine coolant gets into the eyes or contacts
the skin, flush the eyes or wash the skin thor-
oughly, with plenty of water. If engine coolant
is swallowed, induce vomiting and call a physi-
cian immediately.
● Flush the radiator with fresh water, if necessary.
● Tighten the drain plug securely.
● Pour the specified engine coolant through the
radiator cap inlet up to the inlet neck.
NOTE
For engine coolant information, refer to page 5-1.
Bleed air from the system as follows :
1. Shift the transmission into neutral.
Start the engine and let it idle for 2~3 minutes.
2. Snap the throttle 3~4 minutes to bleed air from
the system.
3. Stop the engine and add the engine coolant up to
the radiator cap inlet neck.
4. Repeat the above procedure until no air bleed
from the radiator cap inlet.
and engine coolant
PERIODIC MAINTENANCE 2-12
�
�
①
②
③