Starter Motor Removal - Suzuki GSX-R1000 2007 Service Manual

Step 3
1) Measure the starter relay voltage at the starter relay connectors (between Y/G and B/Y ) when the
starter button is pushed.
Is a voltage OK?
YES
NO
Step 4
1) Check the starter relay. (
Is the starter relay OK?
YES
NO
Starter motor runs but does not crank the engine
Step 1
1) The starter motor runs when the transmission is in neutral, but does not run when the transmission is in
any position other than neutral, with the side-stand up.
2) Check the side-stand switch. (
Is the side-stand switch OK?
YES
NO
Step 2
1) Check the starter clutch.
Is the starter clutch OK?
YES
NO

STARTER MOTOR REMOVAL

• Disconnect the battery  lead wire.
• Lift and support the fuel tank.
• Disconnect the starter motor lead wire .
• Remove the starter motor .
Go to Step 4.
• Faulty engine stop switch
• Faulty clutch switch
• Faulty GP switch
• Faulty turn signal/side-stand relay
• Faulty starter button
• Faulty ignition switch
• Faulty side-stand switch
• Poor contact of connector
• Open circuit in wire harness
9-16)
Poor contact of the starter relay
Faulty starter relay
9-17)
Go to Step 2.
Faulty side-stand switch
Faulty starter clutch
• Open circuit in wire harness
• Poor contact of connector
ELECTRICAL SYSTEM 9-13