Generator Test (Overcharged Battery Check) - Suzuki Grand Vitara 2011 Manual

2) Run engine from idling up to 5,000 rpm with all
accessories turned off and read meters.
If voltage is higher than standard value, check
ground of brushes.
If brushes are not grounded, replace coil assembly.
If voltage is lower than standard value, proceed to
the following check.
Specification for undercharged battery (No-load
check)
Current: 10 A
Voltage: 14.2 – 14.8 V (at 25 °C, 77 °F)
NOTE
Consideration should be taken that voltage
will differ somewhat with regulator case
temperature as shown in figure.
(V)
16.0
15.5
15.2
15.0
14.5
[A]
14.3
14.2
14.0
13.5
13.0
-30 0
22
[A]: Regulated voltage (V)
[B]: Heatsink temperature
3) Remove generator rear end cover.
4) Ground "F" terminal and start engine, then measure
voltage at "B" terminal as shown in figure.
• Voltage is higher than standard value. It is
considered that generator itself is good but IC
regulator has been damaged, replace coil
assembly.
• Voltage is lower than standard value. It is
considered that generator itself has problem,
check the generator.
14.6
14.8
13.3
25 120 (˚C)
77 248 (˚F)
[B]
I6JB0A1A2001-01
"B"
V
"F"
I5JB0B1A0005-01
Charging System: For Diesel Engine Model 1J-21

Generator Test (Overcharged Battery Check)

1) To determine battery condition, refer to "Battery
Description: For Diesel Engine Model".
2) If obvious overcharged condition exists as evidenced
by excessive spewing of electrolyte, measure
generator "B" terminal voltage at engine 5,000 rpm.
3) If measured voltage is higher than upper limit value,
disassemble generator.
4) Check ground of brushes. If brushes are not
grounded, replace coil assembly. Then check field
coil for grounds and shorts.
(V)
16.0
15.5
15.2
15.0
14.5
[A]
14.3
14.0
13.5
13.0
-30 0
22
[A]: Regulated voltage (V)
[B]: Heatsink temperature
S6JB0A1A24004
14.6
14.8
14.2
13.3
25 120 (˚C)
77 248 (˚F)
[B]
I6JB0A1A2001-01