Manual Road Test - Suzuki Grand Vitara 2011 Manual

5A-31 Automatic Transmission/Transaxle:

Manual Road Test

WARNING
!
• Carry out test in very little traffic area to prevent an accident.
• Test requires 2 persons, a driver and a tester.
The purpose of this test is to judge whether causal factor of trouble which occurred in automatic transaxle is electrical
or mechanical by disconnecting valve body connector (1) and fixing automatic transaxle gear position (fail-safe
function).
1) Start engine and warm it up to normal operating temperature.
2) After warming up engine, turn ignition switch to OFF position and disconnect valve body connector (1).
3) Turn OFF all electrical loads.
With shift select lever shifted to each range ("L", "2", "3" and "D") drive vehicle at 1,000 rpm engine speed and then
check vehicle speed by referring to "Fixed gear position".
If vehicle speed is not as specified in "Fixed gear position" table, go to troubleshooting.
4) Connect valve body connector and clear DTC.
Fixed gear position
Select lever position
L range
2 range
3 range
D range
Troubleshooting
Condition
Selected gear is incorrect Faulty valve body component
Fixed gear position
1st gear
3rd gear
4th gear
Possible cause
Faulty clutch or brake
I5JA01511003-01
Vehicle speed
Approx. 9.2 km/h (5.7 mile/h)
Approx. 17.4 km/h (10.8 mile/h)
Approx. 37.7 km/h (23.4 mile/h)
Correction / Reference Item
Replace valve body assembly.
Inspect clutch and brake. If any parts are faulty,
replace them.
S6JB0A5104013