Air Intake System; Air Filter Replacement - Club Car Carryall 1500 Maintenance And Service Manual

15

Air Intake System

AIR INTAKE SYSTEM
See General Warnings, Section 1, Page 1-2.
The air filter intake hose fits between the driver-side frame and the inlet port on the air filter canister. The frame serves
as a duct to carry air from a location at the top of the front of the vehicle.
CAUTION
• Do not drill into the driver-side frame because it is part of the air intake system. Failure to heed this
caution could damage the engine by allowing excessive contamination to enter the air intake system.

AIR FILTER REPLACEMENT

The air filter should be inspected periodically and replaced when necessary. Filter changes should not exceed the
recommended interval. See Periodic Service Schedule, Section 10, Page 10-1. More frequent service may be
required in extremely dirty operating environments. In the event of a loss of power, sluggish acceleration, or a roughly
running engine, service the air filter immediately.
CAUTION
• Do not drill into the driver-side frame because it is part of the air intake system. Failure to heed this
caution could damage the engine by allowing excessive contamination to enter the air intake system.
1
218
Figure 15-22 Air Filter Cartridge
Air Filter Removal
1. Release both canister tab locks (Figure 15-22, Page 15-26).
2. Pull the canister cap away from the canister.
3. Remove the air filter cartridge (1). See following NOTE.
NOTE: The filter cartridge is specifically designed for this engine. It fits into the canister only one way. Use only direct
replacement part (CC P/N 102498601).
Page 15-26 2015 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual
GASOLINE ENGINE, MUFFLER, FUEL
SYSTEM, AND CLUTCHES