Club Car Carryall 1500 Maintenance And Service Manual page 173

TROUBLESHOOTING AND ELECTRICAL SYSTEM:
GASOLINE VEHICLES
WAVETEK 5XL
V
V OFF
1000
500
200 200
20
200
2m
2
200 20
m
m
200
2000
m
k
200k
20k 200
A
2k
! !
V COM 200nA
MAX
1000 ---
FUSED
750V
485
Figure 11-32 Voltage Measurement at Headlight Socket
6. If there is no voltage reading at the wire harness, check the continuity of the 16-gauge blue wires (w01 and
w03) from the headlight to the light switch.
6.1. Set the multimeter to 20 VDC.
6.2. Use an alligator clip to attach the black (–) probe onto the negative (–) battery terminal and place the red
(+) probe into the blue wire terminal (w01) of the wire harness. If the multimeter reading is approximately
12 volts, the blue wire has continuity.
7. Check the continuity of the 16-gauge black wire (w13) from the headlight to the frame ground.
7.1. Set the multimeter to 20 VDC.
7.2. Place the black (–) probe of multimeter into the black wire terminal (w13) of the wire harness and use an
alligator clip to attach the red (+) probe onto the positive (+) battery terminal. If the multimeter reading is
approximately 12 volts, the black wire has continuity.
8. Check the continuity of the headlight jumper harness wires.
9. If the readings are correct in all of the previous steps, replace the headlight bulb.
2101
Figure 11-33 Bed Lift Motor Wires
2015 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual
11
Test Procedures
Page 11-37