Engine Coolant - Diesel Vehicles; Engine Coolant Level Check; Fueling Instructions - Club Car Carryall 1500 Maintenance And Service Manual

PERIODIC MAINTENANCE
ENGINE COOLANT – DIESEL VEHICLES
See General Warnings, Section 1, Page 1-2.

ENGINE COOLANT LEVEL CHECK

The coolant reserve tank (2) is located under the hood on the passenger side (Figure 10-5, Page 10-10). Raise the
hood to check the coolant level before every operation.
Check the coolant level of the reserve tank (2). If the coolant is at or below the LOW mark, add pre-mixed coolant until
level reaches the FULL mark. If a leak is detected, have it checked by a trained technician. See following WARNING.
WARNING
• Coolant reservoir and radiator are pressurized. Remove caps slowly to relieve pressure.
• Hot! Coolant system is pressurized. Do not remove radiator cap while engine is hot.
NOTE: Use a mixture of 45% water and 55% propylene glycol with anti-corrosion additives.

FUELING INSTRUCTIONS

See General Warnings on page 1-2.
DANGER
• Turn the key switch to the OFF position before fueling.
• Do not pour fuel into the fuel tank when the engine is hot or while it is running.
• To avoid electric arc caused by static electricity, the fuel storage/pumping device must be grounded. If
the pump is not grounded, the vehicle must be grounded to the pump before and during the fueling
operation.
• To avoid the possibility of fire, clean up any spilled fuel before operating the vehicle.
1. Remove the fuel cap and fill the tank with fuel. Gasoline vehicles have a black fuel cap; diesel vehicles have
a green fuel cap. See preceding DANGER and following CAUTION.
CAUTION
• Gasoline vehicles: Use unleaded gasoline only.
• Whenever possible, avoid using oxygenated and blended fuels.
• Do not use any fuel with an alcohol content that exceeds 10% by volume (such as E85). Ethanol
is an alcohol that readily absorbs moisture causing corrosion of fuel system components. It also
damages neoprene and other plastic and rubber components. Use of these fuels in this vehicle
will void the warranty.
• Diesel vehicles: Use only diesel fuel grade no. 2 with a cetane rating of 45 or higher.
2015 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual
Engine Coolant – Diesel Vehicles
10
Page 10-19