Club Car Carryall 1500 Maintenance And Service Manual page 205

TROUBLESHOOTING AND ELECTRICAL SYSTEM:
DIESEL VEHICLES
2363
Figure 12-27 Front Differential Switch
3. Move the accelerator pedal and listen for an audible click from the switch. If there is no click, check the limit
switch for proper alignment and switch arm movement.
4. Place the red (+) probe of the multimeter on one terminal and the black (–) probe on the other terminal of the
switch. With the accelerator pedal fully released, the reading should be no continuity.
5. Apply the accelerator pedal to activate the switch. The multimeter should indicate continuity when the switch
lever is activated. If either reading is incorrect, replace the switch. See Front Differential Limit Switch
Removal on page 14-14.
TEST PROCEDURE 20 – Front Drive Gearcase Coil
See General Warnings, Section 1, Page 1-2.
1. Disconnect battery. See Disconnecting the Battery – Gasoline/Diesel Vehicles, Section 1, Page 1-3.
2. Disconnect the two-pin connector between the wire harness and the front drive gearcase located under the front
floorboard.
3. Set the multimeter to 200 ohms.
4. Measure the resistance between the two wires at the two-pin connector (front drive gearcase side).
5. The resistance should be 24.7 to 27.3 ohms.
6. If the resistance is not within the stated range, replace the large output cover sub-assembly. See the Engines
and Drivetrain Components manual (CC P/N 102396501).
2015 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual
12
Test Procedures
Page 12-29