Drivetrain; Clutch And Brake Linkage; Clutch Master Cylinder; Shifter Mechanism Boot - Dodge D150 1990 Service Manual

0 - 22 LUBRICATION AND MAINTENANCE •
DRIVETRAIN
INDEX
Page
Automatic Transmission 24
Axles 25
Clutch and Brake Linkage 22
Clutch Master Cylinder 22
Front Axle Universal Drive Joint and Pivot
Bearings . . 26
CLUTCH AND BRAKE LINKAGE
I f the clutch and brake pedal assembly should s t a r t
to squeak or g r u n t , t h e p i v o t bushings should be l u -
bricated (Fig. 1). Use a m u l t i p u r p o s e ( N L G I Grade 2)
grease, M O P A R Multi-Purpose L u b r i c a n t , or equiva-
lent.
CLUTCH MASTER CYLINDER
The clutch master cylinder f l u i d level should be pe-
riodically inspected w h e n other under hood service is
performed. The f l u i d level i n the reservoir should be
up to the bottom of the l i d r e t a i n i n g collar (Fig. 1). I f
the f l u i d level should become low, locate and correct
any possible leaks a n d f i l l the reservoir w i t h clean,
moisture free brake f l u i d conforming to D O T 3,
Page
Manual Transmissions NP2500 Overdrive
5-Speed/NP435 Overdrive 4-Speed 22
Propeller Shaft Universal Joints . . . . . . . . . . . . . . 26
Transfer C a s e . . 24
(MUSS 116) s t a n d a r d only. M O P A R B r a k e F l u i d or
equivalent w i l l provide the best c l u t c h performance.
CAUTION: Do not allow any petroleum base fluids
to contaminate the clutch hydraulic system, seal
damage will result.
MANUAL TRANSMISSIONS NP2500 OVERDRIVE
5-SPEED/NP435 OVERDRIVE 4-SPEED
SHIFTER MECHANISM BOOT
Inspect b o t h automatic and m a n u a l shifter boots
for stone o r heat damage. Replace, i f necessary.
RESERVOIR
CLUTCH
HOUSING
CLUTCH
PEDAL
VIEW IN DIRECTION
OF ARROW Z
LUBRICATE
23 N i *
(200 IN. LBS.)
MASTER
CYLINDER
COTTER PIN
NUT 23 N*m (200 IN. LBS.)
WAVE WASHER
RETAINING RING
BRAKE PEDAL
VIEW IN DIRECTION FLAT WASHER
OF ARROW Y RR06F1
Fig. 1 Clutch and Brake Pedal Assembly