Table of Contents
Advertisement
DRIVEN
GEAR
J9021-151
Fig. 3 NP205 Speedometer Components.
(5) Disconnect
propeller shafts a t transfer case.
Move shafts aside for w o r k i n g clearance and secure
t h e m t o frame r a i l s w i t h wire.
(6) Disconnect shift r o d from shift lever on transfer
case.
(7) Support transfer case w i t h transmission jack.
(8) Remove bolts/nuts a t t a c h i n g transfer case t o
transmission adapter.
(9) Lower transfer case and move i t f r o m under ve-
hicle.
YOKE NUT
WASHER
SEAL WASHER
REAR YOKE
OIL SEAL
REAR SEAL RETAINER
GASKET
SNAP RING
REAR OUTPUT SHAFT BEARING
SPEEDOMETER GEAR
BEARING RETAINER - REAR
VENT TUBE CONNECTOR
GASKET
REAR OUTPUT SHAFT SUPPORT
BEARING
LOW GEAR RETAINING RING
THRUST WASHER (3/16" THICK)
THRUST WASHER ll/16" THICK)
LOW GEAR ROLLER BEARINGS
liEARING SPACER
LOW GEAR - REAR SHAFT
THRUST WASHER (1/16" THICK)
REAR OUTPUT SHAFT
THRUST WASHER PIN
SLIDING CLUTCH
PILOT BEARING ROLLERS (15)
PILOT BEARING THRUST
WASHER
LOCK RING
INPUT GEAR
IDLER SHAFT COVER
GASKET
IDLER SHAFT
IDLER GEAR BEARINGS
BEARING RACES
BEARING SPACER
IDLER GEAR
IDLER GEAR BEARING SHIMS
WASHER
IDLER SHAFT LOCK NUT
THRUST WASHER PIN
FRONT OUTPUT SHAFT
SLIDING CLUTCH
HIGH GEAR
THRUST WASHER
FRONT OUTPUT SHAFT FRONT
BEARING
BEARING SNAP RING
FRONT OUTPUT SHAFT REAR
BEARING
BEARING RETAINER - FRONT
GASKET
RETAINING RING
THRUST WASHER (3/16" THICK)
LOW GEAR - FRONT SHAFT
LOW GEAR ROLLER BEARINGS
BERING SPAC€R
FLANGE
OIL SEAL
FRONT SEAL RETAINER
GASKET
DRAIN PLUG
©
®
®
®
®
®
©
©
®
©
©
• ©
©
®
®
®
©
CASE MAGNET AND CLIP
FILL PLUG
PTO COVER AND GASKET
GEAR CASE
SHIFT RAIL DETENT BALLS
AND SPRINGS
4WD INDICATOR LIGHT
SWITCH AND GASKET
SHIFT FORK AND RAIL - REAR
WHEEL
INTERLOCK PINS (2)
FORK-TO-RAIL LOCK PIN
SHIFT RAIL OIL SEALS
SHIFT RAIL LINK
RETAINING CLIP (2J
LINK-TO-RAIL RETAINING PIN
HIFT FORK AND RAIL -
FRONT WHEEL
INTERLOCK HOLE PLUGS (4)
FRONT OUTPUT SHAFT
BEARING
BEARING SNAP RING
INPUT SHAFT SNAP RING
ADAPTER OIL SEAL (2)
GASKET
TRANSFER CASE ADAPTER
ADAPTER SLEEVE
SLEEVE RETAINING RING
GASKET
TRANSMISSION ADAPTER
J9021-149
Advertisement
Table of Contents
