Dodge D150 1990 Service Manual page 980

AUTOMATIC TRANSMISSION 21-129
Measurement
(Inches)
Spacer
Part Number
Spacer Thickness
(Inches)
1.7500-1.7649
4431730 - .i08-.no
1.7650-1.7799 4431585 .123-125
1.7800-1.7949 4431731 .138-.140
1.7950-1.8099 4431586 .153-.155
1.8100-1.8249 4431732 .168-.170
1.8250-1.8399 4431587 .183-.185
1.8400-1.8549 4431733 .198-.200
1.8550-1.8699 4431588 .213-.215
1.8700-1.8849 4431734 .228-.230
1.8850-1.8999 4431590 .243-.245
SPACER
GROOVE
J9021-95
Fig. 51 Overdrive Piston Selective Thrust Plate
Chart
GASKET
SHARP KNIFE
8921-269
Fig. 52 Trimming Overdrive Case Gasket
CAUTION: Be sure the shoulder on the inside diam-
eter of the bearing is facing forward.
(6) Carefully raise t h e overdrive u n i t a n d slide i t
straight onto the transmission intermediate shaft. I n -
sert t h e b a l l o n t h e p a r k i n g r o d i n t o t h e reaction
p l u g a t the same t i m e .
SELECTIVE SPACER
INTERMEDIATE
SHAFT
J9021-96
Fig. 53 Intermediate Shaft Selective Spacer Location
CAUTION: Do not tilt the unit during installation.
Tilting the unit could cause the planetary gear and
and overrunning clutch splines to rotate out of
alignment. If this happens, it will be necessary to
remove the overdrive unit and realign the compo-
nents with tool C-6227-2.
(7) A l i g n t h e slip-fit governor tubes and push t h e
overdrive u n i t f o r w a r d u n t i l i t touches the t r a n s m i s -
sion case.
(8) I n s t a l l t h e overdrive u n i t attaching bolts.
T i g h t e n t h e bolts i n a crisscross pattern t o 34 N
#
m
(25 ft-lbs).
(9) I n s t a l l t h e crossmember.
(10) O n four wheel drive models, install t h e t r a n s -
fer case.
(11) I n s t a l l t h e distance sensor and speedometer
adapter. Be sure t o index t h e adapter .
(12) Connect t h e distance sensor a n d overdrive
wires.
(13) A l i g n and i n s t a l l t h e propeller shaft, or shafts
on four wheel drive models.
(14) I f the valve body was also removed, adjust t h e
bands, i n s t a l l t h e v a l v e body a n d install t h e trans-
mission o i l pan.
(15) Lower t h e vehicle and r e f i l l t h e transmission
w i t h Mopar A T F Plus, Type 7176 transmission f l u i d .