MCi Crusader II 1989 Maintenance Manual page 521

Date
1-1-89
Page . ___
17 _ -_ 9 _ _
MC-9 ~AINTENANCE MANll~L
The following chemicals are approved for operation in this flush system.
Supplier
West Chemical Products
2110 E. 37th St
Los Angeles, Calif.
4216 West Street
Long Island, N.Y.
Vapor Corp.
6420 West Howard St.
Chicago, 111. 60648
Trade Name
Teramine
Sanitor
DG-19C
Mixture
1 U.S. pint (.47 liters) liquid chemical to 1 U.S.
gallon (.37 liters) water
1 oz. (29.5 mt) liquid chemical to 1 gallon (3.7
I iters) water
3 parts dry chemical to 11 parts water by volume
Leeder Chemical Co.
16220 Illinois Ave.
Paramount, Calif. 90723
Commode Magic 1 oz. (28.3 grams) dry chemical to 1 gallon (3.7
liters) water
...
TROUBLESHOOTING
TROUBLE
TOILET WILL NOT FLUSH
Pushbutton will not reset air leaking can be heard.
Air regulator hissing.
Water in the air line from pump to pushbutton.
Comb stuck in up position.
Pump is functioning but no water in the bowl.
SHORT FLUSHING CYCLE
(10
SECONDS OPTIMUM)
Comb will not reach full height during flush cycle:
Water bubbling in grid area.
AIR BUBBLES IN TH!= FLUSH
Water level below comb pins.
NOTE: Periodic visual inspection should
be
made of -th!) tank interior for foreign
obiects and/or excessive buildup in the
tank comers due to lack of proper rinsing.
CAUSE
Air line from pump assembly to control valve broken or discon-
nected or cracked or broken lower pan housing.
Defective air regulator.
Pump diaphragm broken.
Replace comb and grid, or replace conical spring if broken.
Broken water line from pump a~sembly to bowl.
Bubbles in the flush pattern.
Hole in the water hose from pump assembly to bowl.
Excessive build-up of debris between pins of comb.
Defective valve in the comb housing area.
1.
Recharge with water and chemical DG-19C.
2. Insufficient amount of water pre-charge.
3. Water in the air line from pump.to pushbutton.
4. Small hole in the pump diaphragm.