MCi Crusader II 1989 Maintenance Manual page 123

Date
1-1-89
Page
MC-9 MAINTENANCE MANUAL
,!AINI GALLEY
DESCRIPTION
A
mini galley is available as optional equipment on MC-9
Coaches. Its major components are a refrigerator, twin coffee
warmers, a cup dispenser, a drip tray, a storage cupboard, and
a switch panel. The unit is fitted at the rear of the coach
between the lavatory and rear seat It is designed to operate on
both the 24-volt DC coach electrical system and a 110-volt AC
in-station power supply.
DRIP TRAY
The hostess center is fitted with a molded fiberglass drip
tray and stainless steel rack to catch spigot drippings and the
runoff from overfilled cups.
The drip tray drains into a small plastic jug located in the
storage cupboard. Because of the jug's small (2 liter) capacity,
it should be emptied and rinsed after each trip.
CUP DISPENSER
The cup dispenser is mounted between the two coffee
warmers. To refill, remove by grasping the cylinder and push-
ing toward rear of coach. This will slide it out of its mounting
bracket. Once released from mounting bracket, it can be filled
with a line of stacked cups (bottom down) and replaced.
COFFEE WARMERS
The coffee warmers are similar to those used in the maxi
galley. By turning the element "OFF" at the switch panel, the
insulated containers are suitable for storing cold beverages.
The warmers can be run off the 24V DC coach electrical
system or off the 11 0V AC in-station electrical system to con-
serve the coach batteries. Unlike the refrigerator, there is no
manual voltage selection necessary. The power switching
controller box automatically switches from 24V to 110V and
back again.
To remove the containers. slide the locking lever on the
switch panel, grasp the spigot, and pull the container out The
containers can then be washed and filled. To reinstall. again
move the locking lever and slide the container in. Push firmly
to ensure that the self-aligning three-pin plug makes contact
There are two phillips screws on the female plug bracket for
adjustment of alignment. The heating elements and spigots
are replaceable.
_,..,.,.,.-"'.,.,--------· ... - ---~t;::==.:::::.,====::=;-
.,
-
""... ~
~-.,
...
--
'
'
'
I•
'
- - - - - - - - - - - - - - - - - - - - - - -""'T
t~~~.~-:-:"j;
;
~~
:l:
Figure 3-46. Mini Galley.