MCi Crusader II 1989 Maintenance Manual page 337

Date
1-1-89 Page
.---10_-1 _ _ _
MC-9 MAINTENANCE MANUAL
Preventive Maintenance (PM) Schedule
The following preventive maintenance schedule is a compilation of suggested maintenance opera-
tions contained in this maintenance manual.
Service intervals may be given as regular intervals (Reg. Int.) months and/or miles. Regular intervals
must be determined by shop personnel based on operating conditions, component failure history and
previous experience. In cases when both time (in months) and miles (in thousands) are given for a
particular operation; maintenance should be performed at whichever interval first occurs.
SERVICE INTERVAL (Miles)
>,
MAINTENANCE OPERATION QI
-
0 0 C)
:'Iii: "'
.5
.c
C)
0 C) 0
0
=.1=
C)
0 0 0
.8
-
ch
0
0
0 0 0
0 0 0
C)
C Cl C)
C
0
0
0
Cl Cl 0 0 0 C) Q Q Q
:I 0
QJ C)
Q ci
,.,;
f/0
Q ,.,; Q
Q
Q
g
II)
_,
::E
a:: ,.,;
,.. ,.. ,..
,..
"'
NC'? LD
,..
N
1 - FRONT AXLE
FRONT AXLE INSPECTION
•
CHECK FRONT AXLE WHEEL ALIGNMENT
•
2-REAR AXLE
CHECK OIL LEVEL - (DIFFERENTIAL)
•
DRAIN & FILL - (DIFFERENTIAL)
•
INSPECT REAR AXLE
•
3- BODY
INSPECT WINDSHIELD WIPERS
•
INSPECT & ADJUST ALL DOORS & LINKAGE 3
INSPECT
& LUBE DRIVER'S SEAT 6
INSPECT \NALL & ROOF SEAMS
•
LUBRICATE SERVICE DOOR HINGES
•
LUBRICATE ENTRANCE DOOR HINGES
•
CHECK
&
LUBRICATE BAGGAGE DOOR LOCKS
•
4 - BRAKES & AIR SYSTEM
.
INSPECT ALL AIR LINES & FITTINGS
•
INSPECT AIR RESERVOIR
•
TEST LOW PRESSURE INDICATOR 6
CLEAN & INSPECT SINGLE CHECK VALVES 6
TEST PRESSURE PROTECTION VALVE OPERATION 3
•
INSPECT FRONT BRAKE HARDVVARE
•
INSPECT & TEST FRONT BRAKE CHAMBERS
•
ti
REPAIR & TEST FRONT BRAKE CHAMBERS 12
CLEAN & INSPECT QUICK RELEASE VALVES 12
.
LUBRICATE BRAKE CAMSHAFTS
•
-
LUBRICATE SLACK ADJUSTERS
•
LUBRICATE BRAKE SHOE ANCHOR PINS
•
INSPECT SLACK ADJUSTERS
•