Club Car 2007 Carryall 295 Maintenance And Service Manual page 367

KAWASAKI GASOLINE ENGINE, MUFFLER, FUEL SYSTEM, AND CLUTCHES
ý
WARNING
• Never attempt to siphon fuel with a hose that does not have a built-in suction device.
• Never attempt to siphon fuel with your mouth.
Figure 13a-9 Gasoline Fuel Tank
13. Disconnect the black wire and orange wire from the fuel level sensor on the tank. Do not remove the
lower nut from the center stud of the sensor.
14. Remove the nut from the strap end below the passenger seat area.
15. Lift the strap end and remove the opposite end from the slotted bracket.
16. Remove the passenger side bed latch bracket from the frame.
17. Remove the fuel tank.
Fuel Tank Storage or Disposal
1. Remove the cap from the tank and thoroughly rinse it with water. The cap may be discarded or kept as
a spare.
2. Use a well-ventilated area and flush the fuel tank with water to remove any remaining fuel.
3. Set the tank upside down in a well-ventilated area so that the water can drain. Allow the tank to sit for 24
hours to dry. See following WARNING.
ý
WARNING
• Dispose of wastewater and fuel tank in accordance with federal, state, and local laws and
ordinances.
4. Store the tank upside down with the cap installed in a well-ventilated area.
Fuel Tank Installation
1. Install the fuel tank in the vehicle.
2. Insert the tab end of the strap into the frame bracket and place the strap in the indentions on the tank.
3. Feed the threaded tab end down into the bottom of the frame. Install a nylon locknut and tighten the nut
to 40 in-lb (4.5 N·m). See following NOTE.
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
13A
Fuel System
Page 13a-15