Club Car 2007 Carryall 295 Maintenance And Service Manual page 198

11B
TROUBLESHOOTING AND ELECTRICAL SYSTEM: HONDA POWERED GASOLINE VEHICLES
TROUBLESHOOTING GUIDE
SYMPTOM
Engine starts but does not run
smoothly.
Engine turns but fails to start.
Engine overheats.
Engine pre-ignites.
Troubleshooting Guide continued on next page...
Page 11b-2 2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
POSSIBLE CAUSES
Spark plug is fouled or in poor condition
Spark plug wire is damaged or loose
Intermittent ignition coil failure
Water or dirt in the fuel system
and/or carburetor;
dirty or clogged fuel filter
Fuel pump malfunction; fuel pressure to
carburetor too low
Fuel tank is empty
Fuel line or filters clogged
Fouled spark plug
Spark plug wire damaged or loose
Engine flooded with fuel as result of
excess choking
Fuel pump malfunction or failure
Ignition coil failure
Kill circuit grounded
Carburetor solenoid failure
Improper idle governor adjustment
Fan screen is partially blocked or plugged
Governor is improperly adjusted
Carburetor is too lean; check main jet size
Excessive carbon deposits on piston head
or in combustion chamber
Spark plug heat range is incorrect
Unsuitable or contaminated fuel
Troubleshooting Guide
REFER TO
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
Test Procedure 15 – Ignition Spark on
page 11b-27, Test Procedure 16 – Engine
Kill Wire on page 11b-28, and Test
Procedure 17 – Grounded Kill Wire on
page 11b-28
Fuel System on page 13b-7
Fuel System on page 13b-7
Fuel System on page 13b-7
Fuel System on page 13b-7
Section 13b – Honda Gasoline Engine,
Muffler, Fuel System, and Clutches
Section 13b – Honda Gasoline Engine,
Muffler, Fuel System, and Clutches
See owner's manual, Controls and
Indicators. See Choke.
Fuel System on page 13b-7
Test Procedure 15 – Ignition Spark on
page 11b-27, Test Procedure 16 – Engine
Kill Wire on page 11b-28, and Test
Procedure 17 – Grounded Kill Wire on
page 11b-28
Test Procedure 17 – Grounded Kill Wire
on page 11b-28
Test Procedure 21 – Carburetor Solenoid
Circuit on page 11b-31
Fuel System on page 13b-7
See the Honda GX620 engine manual
(CCI P/N 102615401).
Fuel System on page 13b-7
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
See the Honda GX620 engine manual
(CCI P/N 102615401).
Fuel System on page 13b-7