Club Car 2007 Carryall 295 Maintenance And Service Manual page 120

10A
PERIODIC MAINTENANCE: HONDA GASOLINE & KUBOTA DIESEL POWERED VEHICLES
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL
Monthly service by owner
or trained technician
First adjustment after 20 hours,
additional every 100 hours of operation
Semiannual service by trained
technician only
(or every 50 hours of operation,
whichever comes first)
Periodic Service Schedule continued on next page...
Page 10a-2 2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
SERVICE
Engine
Tires
Transmission and differentials
General vehicle
Engine (Honda)
Battery
Front wheel alignment and toe-in
Electrical wiring and connections
Brake system
Periodic Service Schedule
Check engine circulating air passage;
visually inspect unshrouded area around
engine exhaust for grass and debris and
clean if necessary.
Diesel vehicles: Check for grass and
debris around the radiator.
Check air pressure and adjust if
necessary. See Section 8 – Wheels and
Tires.
Check lubricant levels. Add if necessary.
See Lubrication Level Check for Front
Differential, Transmission, and Rear
Differential on page 10a-13.
Wash engine compartment and underside
of vehicle. Do not wash engine when hot.
Adjust valve clearance. See Honda
GX620 Service Manual (CCI P/N
102615401).
Clean terminals and wash dirt from
casing; check electrolyte level. Add
distilled water if necessary. See Battery
on page 12b-15 (gasoline vehicles) or
Battery on page 12c-21 (diesel
vehicles).
Check and adjust if necessary. See Wheel
Alignment on page 7-11.
Check for tightness and damage.
Inspect master cylinder, brake lines, and
hoses for damage or leakage.
Check park brake cables for damage;
replace if necessary.
Check brake pads and discs; replace if
necessary. For brake wear-in
procedure, see Hydraulic Brakes in the
Pre-Operation and Daily Safety
Checklist in the Owner's Manual. See
also Section 6 – Hydraulic and Park Brake
Systems