Club Car 2007 Carryall 295 Maintenance And Service Manual page 231

TROUBLESHOOTING AND ELECTRICAL SYSTEM: HONDA POWERED GASOLINE VEHICLES
7. The orange wire should remain disconnected for this step. Place the black probe of the multimeter on the
(3) terminal of the fuel gauge/hour meter and place the red (+) probe on the (1) terminal of the fuel gauge/
hour meter (Figure 11b-29, Page 11b-35). The voltage reading should be the same as the full battery
voltage reading obtained in step 4. If the reading is incorrect, replace the fuel gauge/hour meter.
Remove 18-gauge
orange wire.
WAVETEK 5XL
V
V OFF
1000 500
200 200
20
200
2 2m
200
m 20
m
2000 200
k m
200k
20k 200
2k A
V ! COM ! 200nA
MAX
1000 ---
FUSED
750V
18-GAUGE BLACK
WIRE TO GROUND
Figure 11b-28 Fuel Gauge Voltage Test - Terminal 2
TEST PROCEDURE 26 – HOUR METER
See General Warning, Section 1, Page 1-1.
NOTE: Keep the battery connected during this test procedure.
1. Place the Forward/Reverse handle in NEUTRAL. Chock the wheels.
2. Turn the key switch ON and record the current hour meter reading.
3. Turn the key switch to the START position and hold it until the engine is running smoothly. Release the
key and it will return to the ON position. The engine should idle.
4. Allow the engine to idle for at least 6 minutes (the meter records in 6-minute increments). See following
DANGER.
ý
DANGER
• Do not operate vehicle in an enclosed area without proper ventilation. The engine produces
carbon monoxide, which is an odorless, deadly poison.
5. If the reading does not change after six minutes, check the low oil warning light and the oil pressure
switch. See following NOTE. See also Test Procedure 22 – Low Oil Warning Light Circuit on
page 11b-32.
NOTE: The hour meter is designed to record actual engine running time and will not start adding incre-
ments until the oil pressure switch has opened.
6. If the hour meter still does not function after the low oil warning light, oil pressure switch, and all of the
appropriate wires have been checked for continuity, replace the fuel gauge/hour meter.
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
18-GAUGE
BLUE WIRE
18-GAUGE
WHITE WIRE
18-GAUGE
ORANGE
WIRE
WAVETEK 5XL
V OFF V
1000 500
200 200
20
200
2 2m
200 20
m
m
200
2000
k m
200k
20k 200
2k A
! !
V COM 200nA
MAX
1000 ---
FUSED
750V
Figure 11b-29 Fuel Gauge Voltage Test - Terminal 1
11B
Test Procedures
Page 11b-35