Club Car 2007 Carryall 295 Maintenance And Service Manual page 239

TROUBLESHOOTING AND ELECTRICAL SYSTEM: DIESEL VEHICLES
TROUBLESHOOTING GUIDE
SYMPTOM
Loss of engine power, continued.
Low oil warning light stays on.
High oil pressure.
Low oil pressure.
Engine overheats.
Troubleshooting Guide continued on next page...
2007 Carryall 295/295 SE & XRT 1550/1550 SE Gasoline, Diesel and IntelliTach M & S Manual
POSSIBLE CAUSES
Clutches are not backshifting properly
Low cylinder compression
Incorrect injection timing
Seized engine parts
Uneven fuel injection
Poor injection nozzle performance
Oil level is low
Oil level sensor failure
Low oil warning circuit malfunction
Improper engine oil
Relief valve failed
Oil level is low
Oil strainer clogged
Oil filter clogged
Relief valve clogged with dirt
Relief valve spring is weak or broken
Excessive clearance or crankshaft
bearing
Excessive clearance of rocker arm boss
Oil passage clogged
Oil pump failure
Improper engine oil
Oil level is low
Failed radiator fan or radiator fan circuit
Thermostat switch failure
Fan relay failure
Low engine coolant level
Radiator fins clogged with dust
Internal radiator corrosion
Coolant lines corroded
Failed radiator cap
Troubleshooting Guide
REFER TO
Clutches on page 13c-27
See the Kubota D722 diesel engine
manual (CCI P/N 102615501).
Add engine oil. See owner's manual.
See the Kubota D722 diesel engine
manual (CCI P/N 102615501).
Test Procedure 27 – Low Oil Warning
Light Circuit on page 11c-44
See the Kubota D722 diesel engine
manual (CCI P/N 102615501).
Add engine oil. See owner's manual.
See the Kubota D722 diesel engine
manual (CCI P/N 102615501).
Drain engine oil and refill with specified
engine oil. See owner's manual.
Add engine oil. See owner's manual.
Test Procedure 12 – Fan Motor on
page 11c-27
Test Procedure 11 – Thermostat Switch on
page 11c-25
Test Procedure 10 – Fan Relay on
page 11c-23
Add coolant. See owner's manual.
Clean radiator fins.
Clean or replace radiator. See
Section 15 – Radiator and Coolant
System (Diesel)
Clean or replace coolant lines. See
Section 15 – Radiator and Coolant
System (Diesel)
Replace radiator cap.
11C
Page 11c-3