Section 18 - Decals, Ce Models - Mec Speed Level Series Service & Parts Manual

Secton 18 - Decals, CE Models
Decals, ES Models, CE Specification - Part 1 Decals, ES Models, CE Specification - Part 1
1
5
6
9
2684
12
3084
WARNING
MAXIMUM PLATFORM CAPACITY
EVENLY DISTRIBUTED
680 kg
5-PERSONS
15
91850
LOCATE CONTROL BOX HERE
17
FOR NORMAL OPERATION OF THIS UNIT
7155
Sigma Level
ART_3398
Page 321
3084ES
2
2684ES
7
INSPECT MACHINE AND MAKE SURE THAT IT IS OPERATING PROPERLY,
THAT ALL NAME PLATE AND SAFETY AND CONTROL DECALS ARE IN PLACE
AND LEGIBLE, AND THAT THE MACHINE IS IN ACCORDANCE WITH THE
MANUFACTURER'S MAINTENANCE REQUIREMENTS CONTAINED IN THE
OPERATION AND MAINTENANCE MANUAL AND THE DAILY SAFETY CHECKLIST.
OPERATE MACHINE WITH EXTREME CAUTION. WATCH FOR OBSTRUCTIONS
WHICH MAY STRIKE PLATFORM, PERSONNEL, CONTROLS, OR MACHINE.
OPERATE CONTROLS SLOWLY FOR SMOOTH PLATFORM MOTION.
FOR DRIVING WITH PLATFORM LOWERED:
DO NOT EXCEED MAXIMUM PLATFORM OR
EXTENSION LOAD LIMIT CAPACITY.
LOAD TO BE UNIFORMLY DISTRIBUTED.
PLACE LOAD NEAR CENTER OF PLATFORM
WHEN POSSIBLE.
DO NOT DRIVE ON SIDE SLOPE IF PLATFORM
IS OVER 5% OFF LEVEL.
DO NOT DRIVE UP OR DOWN A GRADE OF
OVER 40%.
FOR DRIVING WITH PLATFORM ELEVATED:
DRIVE ONLY ON A SMOOTH, FIRM, AND PLANAR
SURFACE FREE OF OBSTRUCTIONS.
DO NOT EXCEED MAXIMUM PLATFORM OR
EXTENSION LOAD CAPACITY.
LOAD MUST BE UNIFORMLY DISTRIBUTED.
IF TILT WARNING LIGHT ILLUMINATES OR
TILT ALARM SOUNDS LOWER PLATFORM
AND RE-LEVEL
USE EXTREME CAUTION.
IMPROPER OPERATION OF THIS MACHINE
COULD CAUSE DEATH OR SERIOUS INJURY.
13
MAXIMUM
WIND SPEED
12.5 M/S
45 KM/H
MAXIMUM
SIDE LOAD
400 N
91944
16
7156
Speed Level Seres - Servce & Parts Manual
8
YOU MUST NOT OPERATE
UNLESS YOU HAVE BEEN AUTHORIZED TO
USE AND TRAINED IN THE SAFE OPERATION
OF THIS MACHINE.
TRAINING INCLUDES COMPLETE KNOWLEDGE OF
THE SAFETY AND OPERATION INSTRUCTIONS
CONTAINED IN THE MANUFACTURERS MANUAL,
ANSI MANUAL OF RESPONSIBILITIES, YOUR
EMPLOYERS WORK RULES AND APPLICABLE
GOVERNMENTAL REGULATIONS.
AN UNAUTHORIZED AND UNTRAINED OPERATOR
SUBJECTS THEMSELF AND OTHERS TO
OTHER HAZARDS
DEATH OR SERIOUS INJURY.
1. DO NOT EXCEED PLATFORM LOAD CAPACITY.
2. DO NOT EXCEED MAXIMUM SIDE FORCE AND
MAXIMUM NUMBER OF OCCUPANTS.
3. DO NOT USE WITHOUT GUARD RAILS IN PLACE,
AND ENTRY GATE PROPERLY SECURED.
MAINTAIN SAFE CLEARANCE FROM ELECTRICAL
4. DO NOT USE IF WORK PLATFORM IS NOT WORKING
LINES AND APPARATUS. YOU MUST ALLOW FOR
PROPERLY OR IF ANY PART IS DAMAGED OR WORN.
MACHINE SWAY, ROCK OR SAG AND ELECTRICAL
5. DO NOT USE NEAR MOVING VEHICLES OR CRANES. LINES SWAYING.
6. DO NOT STAND OR SIT ON GUARDRAILS,
THIS MACHINE DOES NOT PROVIDE PROTECTION
ALL PERSONNEL SHALL ALWAYS MAINTAIN FIRM
FROM CONTACT WITH OR PROXIMITY TO AN
FOOTING ON PLATFORM FLOOR.
ELECTRICALLY CHARGED CONDUCTOR.
7. DO NOT USE WHILE UNDER THE INFLUENCE OF
ALCOHOL OR DRUGS.
YOU MUST MAINTAIN A CLEARANCE OF AT
LEAST TEN (10) FEET BETWEEN ANY PART
8. DO NOT OVERRIDE SAFETY DEVICES.
OF THIS MACHINE OR ITS LOAD AND ANY
9. DO NOT LEAVE MACHINE UNATTENDED WITH KEY
ELECTRICAL LINE OR APPARATUS CARRYING UP
IN THE SWITCH.
TO 50,000 VOLTS. ONE FOOT OF ADDITIONAL
10. DO NOT RAISE PLATFORM WHILE MACHINE IS ON
CLEARANCE IS REQUIRED FOR EVERY
A TRUCK, FORKLIFT, OR OTHER DEVICE OR VEHICLE.
ADDITIONAL 30,000 VOLTS OR LESS.
11. DO NOT USE LADDER, SCAFFOLDING, OR OTHER
DEVICES TO INCREASE SIZE OR WORKING HEIGHT
OF PLATFORM.
12. DO NOT ENTER OR EXIT PLATFORM WHILE IN MOTION.
13. DO NOT RECHARGE BATTERIES NEAR
SPARKS OR OPEN FLAME, BATTERIES EMIT
HIGHLY EXPLOSIVE HYDROGEN GAS.
14. DO NOT PERFORM SERVICE ON THE MACHINE WITHOUT
PROPERLY SUPPORTING ELEVATING ASSEMBLY.
15. DO NOT ATTACH OVERHANGING LOADS OR
INCREASE PLATFORM SIZE.
91846
10
DISTANCE FROM GROUND TO LADDER WILL VARY WITH GROUND VARIATIONS.
CHECK DISTANCE BEFORE LEAVING PLATFORM.
18
CE Speed Level™ ES Models: Sheet 1 of 4
ES MODELS - CE
TIP-OVER HAZARDS
THIS MACHINE:
DO NOT DRIVE NEAR DROP-OFFS,
HOLES, OPEN ELEVATOR SHAFTS,
AND LOADING DOCKS
ELECTROCUTION HAZARD
THIS MACHINE IS NOT INSULATED
DO NOT ELEVATE PLATFORM ON
UNEVEN OR SOFT SURFACES
DO NOT DRIVE ONTO UNEVEN OR
SOFT SURFACES WHEN ELEVATED
DO NOT RAISE PLATFORM IN
WINDY OR GUSTY CONDITIONS
DEATH OR SERIOUS INJURY DEATH OR SERIOUS INJURY
WILL RESULT FROM CONTACT WILL RESULT FROM IMPROPER
OR INADEQUATE CLEARANCE USE OF THIS EQUIPMENT
CERTIFIED LANYARD
11
ANCHORAGE POINT
14
91849
19
20
January 2019
91845
8605
91934
91932
Decals