Factory Five Racing MK4 ROADSTER Assembly Manual page 535


In some cases not all parts listed below will be necessary, but it is suggested to obtain all parts to avoid future difficulties.
PART NAME CHECK
Engine
Engine mount, (L,R) w/nuts and bolts
Starter
Transmission, bell-housing, clutch, and shifter components
Transmission mount w/nuts and bolts
Driveshaft w/4 bolts
Clutch cable w/bell-housing retaining c-clip
Speedometer cable (87-93 applications only)
Speedometer speed sensor w/plastic gear
Mass air sensor with flexible elbow
Oxygen sensors
Exhaust headers w/nuts and bolts
Heater hoses to firewall w/clamps
Radiator w/clamps
Fan shroud or shroud with attached fan
Coolant overflow tank w/cap
Fuel tank w/plastic under tray, gas cap, and mounting straps
Filler neck
Fuel filter w/mounting bracket and hoses
High pressure fuel line, tank to filter
Low pressure return line to fuel tank
High and low pressure solid fuel lines attached to engine fuel rails
Fuel evaporative canister, solenoid and tubing
Front and rear brake rotor/drum, calipers, pads, flexible lines, etc.
Mount front and rear brake line, riveted to donor
Master cylinder, w/distribution block
Hydro boost with all power assist lines (96-04 applications only)
Front and rear wheels with lug nuts
emergency brake handle, w/t-junction
Emergency brake cables w/hardware
Rear quad shocks w/mounts nuts and bolts
Spindles, front
Rear upper control arms w/nuts and bolts
Rear lower control arms w/nuts and bolts
8.8inch complete rear axle assembly
Rear coil springs w/OEM rubber isolating pads
Front lower A-arms w/nuts and bolts
Power steering lines if using power steering
Steering rack with mounting bushings
Inner and outer tie-rod ends (87-93 applications only)
Wiring harness (all)
Emergency inertia cut-off switch
Turn signal stalk, and ignition cylinder w/key from steering column
Horns
Vacuum reservoir, black plastic cylinder shaped
Battery w/ground cable
Coil, starter solenoid
EEC IV Computer w/holder
Brake/clutch pedal box w/brake sensor, retaining clip, washers
Accelerator pedal
Gauge cluster 534
www.factoryfive.com 508-291-3443